Pinion Clearance - Adjust
电起动马达
安装电磁阀时,应对小齿轮间隙进行调整。 该调整可在起动马达被拆下时进行。
Show/hide table
图 1 | g01134792 |
检查小齿轮间隙时所用的接头 (1) 接地端子 (2) 开关端子 (3) 马达接头 |
- 不带电磁阀的马达接头(接线端子)到马达之间的连接片 (3) 时,直接安装电磁阀。
- 将来自与电磁阀具有相同电压的蓄电池的正极连接到 "SW" 接线端子 (2) 。
- 将蓄电池的负极连接到接地端子 (3) 上。
- 短时间用导线把带有 "MOTOR(马达)"标记的电磁阀接头(接线端子)与接地接头(接线端子)相连。 小齿轮会输出并停留在盘车位置,直到断开蓄电池为止。
- 将小齿轮推向整流子一侧以消除其自由行程。
Show/hide table
图 2 | g01454593 |
(4) 轴螺母 (5) 小齿轮 (A) 小齿轮间隙 |
- 小齿轮间隙 (A) 必需为 9.1 mm (0.36 in)。
- 调整小齿轮间隙时,应拆下螺塞,转动轴螺母 (4) 。
- 调整结束后,在螺母 (4) 上方安装螺塞,然后在电磁阀的 MOTOR(马达)端子与起动马达之间安装接头 (3) 。
Caterpillar Information System:
3512B Petroleum Engines with the ADEM 2 Electronic Control Module MID 036 - CID 0342 - FMI 07 Secondary Speed Sensor misinstalled
3512B Petroleum Engines with the ADEM 2 Electronic Control Module MID 036 - CID 0190 - FMI 07 Primary Speed Sensor misinstalled
3408E and 3412E Engines for Caterpillar Built Machines Cooling System - Test
325D and 329D Excavators Hydraulic System Check Valve (Load)
3126B Engines Piston Ring Groove - Inspect
320D Excavator Cab Visor - If Equipped
325D and 329D Excavators Roof Hatch
2000/03/13 Use 152-1057 Fuel Injector Installer For Engine Bore Insertion {0706, 1290}
Replacing Bonded Windows {7310} Replacing Bonded Windows {7310}
321B LCR Excavator Alternate Exit
3126 Truck Engine (Military) Vibration Damper - Check
3408E and 3412E Engines for Caterpillar Built Machines Engine Oil Pressure - Test
3512B Engine for SPF343, SPS343, and SPT343 Pumpers MID 036 - CID 0336 - FMI 02 Incorrect ECS Switch inputs
3306C Engines for Caterpillar Built Machines Charging System - Test
3412C Engine Water Temperature Regulator - Test
3500B and 3500B High Displacement Generator Set Engines MID 036 - CID 0828 - FMI 08 Right Exhaust Temperature signal abnormal
3408E and 3412E Engines for Caterpillar Built Machines Valve Mechanism Cover
3412C Engine Piston Ring Groove - Inspect
C-9 Engine for TK711, TK721, TK722, TK732, TK741, TK751, and TK752 Track Feller Bunchers Event Codes
3126B Engines Electric Starting System - Test
3306C Engines for Caterpillar Built Machines Battery - Test
3512 and 3516 EUI Engines for Caterpillar Built Machines General Information (Air/Electric Starting System)
325D and 329D Excavators Hydraulic System Accumulator (Pilot)
3412C Engine Vibration Damper - Check