Fuel System Filter - Replace
Show/hide table
| NOTICE |
|---|
Turn the disconnect switch OFF or disconnect the battery when changing fuel filters. Do not fill fuel filters with fuel before installing them. Contaminated fuel will cause accelerated wear to fuel systems parts. |
- Remove firewall (2) .
Note: Refer to Operation and Maintenance Manual, "General Hazard Information" for information on containing fluid spillage.
Show/hide table
 | |
| Illustration 1 | g00868952 |
Location of fuel filter (1) Fuel filter (2) Firewall | |
- Remove filter (1) .
Note: This fuel filter is a cartridge type filter. This type of filter cannot be reused.
Note: Always discard used filters according to local regulations.
- Clean the filter mounting base. Make sure that all of the used seal is removed.
- Coat the seal of the new filter with clean diesel fuel.
- Install the new fuel filter by hand. When the seal contacts the filter mounting base, tighten the filter by an additional 3/4 turn.
- Prime the fuel system. See Operation and Maintenance Manual, "Fuel System Priming Pump - Operate" for instructions.
- Close the engine hood.
Caterpillar Information System:
365B, 365B Series II, 365BL, 385B and 5090B Excavators Machine Electronic Control System MID 039 - CID 1191 - FMI 07
303 CR Excavator Electric and Electronic System Starting Motor Does Not Rotate - Troubleshoot
365B, 365B Series II, 365BL, 385B and 5090B Excavators Machine Electronic Control System MID 039 - CID 1193 - FMI 13
321B LCR Excavator Engine Oil and Filter - Change
325C Excavator Machine Systems Fuel Tank - Remove
N3 Series Brushless Alternators Stator - Test
365B, 365B Series II, 365BL, 385B and 5090B Excavators Machine Electronic Control System MID 039 - CID 1166 - FMI 13
GH52,GH55,GH60 Hydraulic Excavator Forestry Grapples Swivel Leakage - Test
365B, 365B Series II, 365BL, 385B and 5090B Excavators Machine Electronic Control System MID 039 - CID 1165 - FMI 13
312C Excavator Machine Systems Stick Bearings and Seals - Install
303 CR Mini Hydraulic Excavator Fuel System Filter - Replace
385B and 5090B Excavators Excavator Systems Bucket Cylinder - Assemble
311B, 312B, 315B, 318B, 320B, 322B, 325B, 330B, 345B, 345B Series II, 365B and 385B Excavators Air Conditioning and Heating System Capacities for Refrigerant (Excavators) - 311B-385B
314C CR Excavator Hydraulic System Gear Pump (Pilot)
308C CR Excavator Hydraulic System Travel Hydraulic System
GH52,GH55,GH60 Hydraulic Excavator Forestry Grapples Host Machine Pressure and Flow - Test
312C Excavator Machine Systems Stick - Remove
385B and 5090B Excavators Excavator Systems Boom Bearings and Seals - Remove
2002/05/27 A New Cover Assembly Is Available For Preventing the Accumulation of Debris in the Battery Compartment {1401}
321B LCR Excavator Fuel System Water Separator - Drain
321B Excavator Hydraulic System Cylinder Drift - Check - Loaded Bucket
303 CR Mini Hydraulic Excavator Hydraulic System Main Hydraulic Pump
314C CR Excavator Hydraulic System Hydraulic Filter (Pilot)
5090B Excavator Battery Disconnect Switch