Hydraulic Tank
Show/hide table
图 1 | g01693613 |
注: 将 4C-4030 螺纹锁固胶 涂抹在螺母 (1) 的螺纹上。
(1) 22 个螺母的扭矩 ... 16 ± 1 N·m (140 ± 9 lb in)
(2) 将 9S-3263 螺纹锁固胶 涂抹在吸油滤网的螺纹上。
(3) 目测表总成 (4) 的两个螺栓的扭矩 ... 9.0 ± 0.9 N·m (80 ± 8 lb in)
(5) 断路器安全阀的扭矩 ... 15 ± 3 N·m (135 ± 27 lb in)
(6) 温度传感器总成的最大扭矩 ... 2.26 N·m (20 lb in)
(7) 废弃机油滤清器总成的垫片。
Show/hide table
图 2 | g01693635 |
剖面 A-A |
使用以下步骤拧紧四个螺母:
- 在螺母的螺纹上涂抹 4C-4030 螺纹锁固胶 。
- 请参阅图 2 以便按顺序拧紧螺母 (1) 至 (4) ,如图所示。
- 按顺序将螺母拧紧至 16 ± 1 N·m (140 ± 9 lb in),如图所示。
吸油滤清器
Show/hide table
图 3 | g01218021 |
冷起动释放 ... 20.7 kPa (3 psi)
流量为 283 L/min (75 US gpm) 时的压降 ... 2.4 kPa (0.5 psi)
过滤 ... 140 微米
W/225 SSU 机油的温度 ... 37.7 °C (99.9 °F)
Caterpillar Information System:
C15 and C18 Engines for Caterpillar Built Machines Sensors and Electrical Connectors
834H Wheel Dozer and 836H Landfill Compactor Electrohydraulic System MID 082 - CID 1964 - FMI 03
C11 and C15 Engines for Caterpillar Built Machines Digital Sensor Supply Circuit - Test
267B, 277B and 287B Multi Terrain Loaders Power Train Piston Pump (Hydrostatic) - Install
267B, 277B and 287B Multi Terrain Loaders Power Train Piston Pump (Hydrostatic) - Remove
793D Off-Highway Truck Power Train Relief Valve (Torque Converter Outlet) - Remove and Install
793D Off-Highway Truck Power Train Drive Shaft Guard (Rear) - Remove and Install
C11 and C15 Engines for Caterpillar Built Machines 5 Volt Engine Pressure Sensor Supply Circuit - Test
834H Wheel Dozer and 836H Landfill Compactor Power Train Transmission, Input Transfer Gears and Output Transfer Gears - Remove
793D Off-Highway Truck Power Train Drive Shaft Guard (Front) - Remove and Install
834H Wheel Dozer and 836H Landfill Compactor Electrohydraulic System MID 082 - CID 1964 - FMI 01
793D Off-Highway Truck Power Train Relief Valve (Torque Converter Inlet) - Remove and Install
AP-1055D and BG-2455D Asphalt Pavers Machine Systems Piston Pump (Right Drag Conveyor and Left Auger Conveyor) - Install
PM-201 Cold Planer Daily Inspection
966H and 972H Wheel Loaders Machine Systems Piston Pump (Brake, Hydraulic Fan) - Disassemble
966H and 972H Wheel Loaders Machine Systems Piston Pump (Brake, Hydraulic Fan) - Assemble
PM-201 Cold Planer Moldboard Down Pressure Adjustment
AP500F Asphalt Paver Machine Systems Feeder Drive Shaft Group - Disassemble
834H Wheel Dozer and 836H Landfill Compactor Electrohydraulic System MID 082 - CID 1964 - FMI 04
AP-1055D and BG-2455D Asphalt Pavers Machine Systems Piston Pump (Left Drag Conveyor and Right Auger Conveyor) - Remove
C11 and C15 Engines for Caterpillar Built Machines Ether Injection System - Test
R2900G Load Haul Dump Ride Control Accumulator - Check - If Equipped
PM-201 Cold Planer Air Compressor - Inspect
PM-201 Cold Planer Air Tank - Drain