Daily Inspection
Show/hide table
注意 |
---|
机器上淀积的润滑脂和润滑油有引发火灾的危险。 用蒸汽或高压水来清除这些污物,至少每 1000 小时一次,或每当有大量的油溢漏在机器上时就要进行一次。 |
关于详细程序,参见保养部分。 关于定期保养的完整列表,参见保养周期表。
Show/hide table
发动机排气中含有燃烧产物,燃烧产物对人体健康是有害的 必须在良好通风的场所起动和运转发动机,如果在封闭场所,要将废气排到外面去。 |
Show/hide table
图 1 | g01140681 |
有两种固定机器的方法:
- 将机器升起至最大高度。 安装维修支架。
- 降下机器直到转筒着地。
参考参见操作和保养手册, "维修支架(支腿锁)"。
注: 这两种方法可防止机器在维修时的移动。
为了使机器的使用寿命最长,总是要进行机器的绕行检查。 在你起动发动机之前必须进行绕行检查。 在你起动发动机之前必须进行绕行检查。
在机器周围和下方查找有无诸如松动螺栓、垃圾、机油泄漏、冷却液泄漏、断裂或磨损的零件之类的东西。 检查附件的状况。 检查履带和液压部件的状况。 进行所有必要的修理。
Caterpillar Information System:
AP-1055D and BG-2455D Asphalt Pavers Machine Systems Piston Pump (Right Drag Conveyor and Left Auger Conveyor) - Install
RM-500 Road Reclaimer/Soil Stabilizer Machine Systems Hydraulic Tank
C15 and C18 Engines for Caterpillar Built Machines Sensors and Electrical Connectors
834H Wheel Dozer and 836H Landfill Compactor Electrohydraulic System MID 082 - CID 1964 - FMI 03
C11 and C15 Engines for Caterpillar Built Machines Digital Sensor Supply Circuit - Test
267B, 277B and 287B Multi Terrain Loaders Power Train Piston Pump (Hydrostatic) - Install
267B, 277B and 287B Multi Terrain Loaders Power Train Piston Pump (Hydrostatic) - Remove
793D Off-Highway Truck Power Train Relief Valve (Torque Converter Outlet) - Remove and Install
793D Off-Highway Truck Power Train Drive Shaft Guard (Rear) - Remove and Install
C11 and C15 Engines for Caterpillar Built Machines 5 Volt Engine Pressure Sensor Supply Circuit - Test
834H Wheel Dozer and 836H Landfill Compactor Power Train Transmission, Input Transfer Gears and Output Transfer Gears - Remove
793D Off-Highway Truck Power Train Drive Shaft Guard (Front) - Remove and Install
966H and 972H Wheel Loaders Machine Systems Piston Pump (Brake, Hydraulic Fan) - Disassemble
966H and 972H Wheel Loaders Machine Systems Piston Pump (Brake, Hydraulic Fan) - Assemble
PM-201 Cold Planer Moldboard Down Pressure Adjustment
AP500F Asphalt Paver Machine Systems Feeder Drive Shaft Group - Disassemble
834H Wheel Dozer and 836H Landfill Compactor Electrohydraulic System MID 082 - CID 1964 - FMI 04
AP-1055D and BG-2455D Asphalt Pavers Machine Systems Piston Pump (Left Drag Conveyor and Right Auger Conveyor) - Remove
C11 and C15 Engines for Caterpillar Built Machines Ether Injection System - Test
R2900G Load Haul Dump Ride Control Accumulator - Check - If Equipped
PM-201 Cold Planer Air Compressor - Inspect
PM-201 Cold Planer Air Tank - Drain
PM-201 Cold Planer Backup Alarm - Test
834H Wheel Dozer and 836H Landfill Compactor Electrohydraulic System MID 082 - CID 1964 - FMI 08