Air Starting Motor - Remove
Show/hide table
所需工具 | |||
工具 | 零件号 | 零件描述 | 数量 |
A | FT-3089 | 弯头套筒 | 1 |
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损並縮短部件使用寿命。 |
注: 有几种不同的气动马达可供使用。 气动马达可以有不同的空气管路配置。 下面是拆卸两个不同气动马达的示例。
- 切断压缩空气的供应。 净化空气管和空气起动马达中排出的加压空气。
Show/hide table
图 1 g01257888 - 断开软管组件 (1)。
- 拆下螺栓 (2 )。
- 拆下管接螺母 (3) 和空气管组件 (4)。
Show/hide table
图 2 g00597643 - 断开软管组件 (5)。
- 将适当的起吊设备连接在空气起动马达 (6) 上。 空气起动马达 (6) 的重量约为
48 kg (106 lb) 。 - 使用工具 (A) 拆下螺栓 (7)。 卸下空气起动马达 (6)。 从气动马达盖和飞轮壳体之间的接头上拆下密封垫。
- 切断压缩空气的供应。 净化空气管和空气起动马达中排出的加压空气。
Show/hide table
图 3 g01049692 - 断开线束组件 (8)。
- 从弯头 (9) 上断开供气管。
Show/hide table
图 4 g01049697 - 将适当的起吊设备连接在空气起动马达 (11) 上。 带有空气管组件的气动马达 (11) 的重量约为
86 kg (190 lb) 。 - 使用工具 (A) 拆下螺栓 (10)。 卸下空气起动马达 (11)。 从气动马达 (11) 的盖和飞轮壳体之间的接头上拆下密封垫。
Caterpillar Information System:
3500 and 3500B High Displacement Engines for Caterpillar Built Machines Air Starting Motor - Install
3500 and 3500B High Displacement Engines for Caterpillar Built Machines Air Starting Motor - Disassemble
3500 and 3500B High Displacement Engines for Caterpillar Built Machines Air Starting Motor - Assemble
G3520B Engines Desired Speed Input (4 - 20 mA)
C-10, C-12 and C-15 On-highway Engines Diagnostic Codes
G3520B Engines Analog Sensor Signal
3054E Industrial Engine Engine Design
3512 and 3516 EUI Engines and 784B, 785B, 789B and 793B Off-Highway Truck/Tractors Aftercooler
C11, C13 and C15 On-highway Engines Vehicle Activity Report Parameters
C11, C13 and C15 On-highway Engines Driver Reward
C-10, C-12 and C-15 On-highway Engines Data Link Parameters
C-10, C-12 and C-15 On-highway Engines Output Selections
3054C and C4.4 Industrial Engine and Marine Auxiliary Engine Crankshaft - Steel Crankshaft
3054E Industrial Engine Main Bearing Journal - Steel Crankshaft
414E, 416E, 420E and 430E Backhoe Loaders General Information
3126B Engine for Caterpillar Built Machines Injection Actuation Pressure - Test
G3520B Engines Detonation Sensors
3056E Industrial Engine Fuel Injection Timing - Check
C7 and C9 On-Highway Engines 0102-01 Low Boost Pressure (25)
C7 and C9 On-Highway Engines 0102-02 Boost Pressure signal erratic
C-10, C-12 and C-15 On-highway Engines 0102-07 Boost Pressure not responding
C-10, C-12 and C-15 On-highway Engines 0173-00 High Exhaust Gas Temperature Derate
C-10, C-12 and C-15 On-highway Engines 0173-11 Very High Exhaust Gas Temperature Derate
3056E Industrial Engine Finding Top Center Position for No. 1 Piston