E100 Low Engine Oil Pressure Warning
产生此代码的情况:
电子控制模块(ECM)检测到以下所有情况:
- 发动机以低怠速上下 50 转/分的转速运转了至少十秒钟。
- 发动机机油压力低的情况达四秒钟。
- 100-03 "发动机机油压力开路/短接到蓄电池正极"处于非当前状态。
- 100-04 "发动机机油压力接地短路"处于非当前状态。
系统响应:
ECM 会记录此事件。
- 无
- 发动机润滑系统可能存在问题。
- 发动机机油压力传感器可能存在问题。
测试步骤 1. 检查有无"当前"诊断代码
- 启动卡特彼勒电子技师(ET)。
- 将钥匙开关转到 ON 位置。
- 检查有无当前或记录的诊断代码。
预期结果:
没有任何诊断代码存在。
结果:
- 与预期结果相符 - 没有任何诊断代码存在。 继续执行测试步骤 2。
- 与预期结果不相符 - 有诊断代码存在。
修复: 修正存在的诊断代码。 请参考本手册"对诊断代码进行故障诊断和排除"部分的相应主题。 确保修正后问题被排除。
停止
测试步骤 2. 检查发动机润滑系统。
- 检查发动机润滑系统。 请参考故障诊断和排除, "发动机机油压力低"部分的诊断程序。
预期结果:
发动机机油压力存在问题。
结果:
- 与预期结果相符 - 发动机机油压力存在问题。
修复: 修正问题。 确保修正后问题被排除。
停止
- 与预期结果不相符 - 发动机机油压力没问题。 可能存在间歇性问题。
修复: 监测发动机的运转。 修正问题。 确保修正后问题被排除。
停止
Caterpillar Information System:
Electronic Modular Control Panel II+ (EMCP II+) Starting Motor Remains Engaged (for EUI and PEEC Engines)
K65-12B Voltage Regulator Electrical
Electronic Modular Control Panel II+ (EMCP II+) System Communication Module (Customer)
Electronic Modular Control Panel II+ (EMCP II+) Synchronizing Lights Module
Electronic Modular Control Panel II+ (EMCP II+) Relay Driver Module
C18 Marine Auxiliary Engine Model View Illustrations
G3500 Generator Sets Voltage Regulators
Electronic Modular Control Panel II+ (EMCP II+) Diagnostic Codes
Electronic Modular Control Panel II+ (EMCP II+) Engine Setpoint Verification OP9
3512 and 3516 EUI Engines and 784B, 785B, 789B and 793B Off-Highway Truck/Tractors Water Pump
Electronic Modular Control Panel II+ (EMCP II+) Voltmeter/Ammeter Programming OP8
3056E Industrial Engine Water Pump
3056E Industrial Engine Flywheel
G3500B Engines Water Pump - Aftercooler
G3500B Engines Turbocharger
3412E, C30 and C32 Marine Engines Turbocharger Outlet Pressure Sensor - Remove and Install
3412E, C30 and C32 Marine Engines Engine Speed/Timing Sensor Circuit - Test
K65-12B Voltage Regulator General Information
PMG3516 Power Module Rotating Rectifier - Test
3412E, C30 and C32 Marine Engines Engine Synchronize Switch Circuit - Test
K65-12B Voltage Regulator Manual Voltage Control
K65-12B Voltage Regulator Voltage Droop Control
3056E Industrial Engine Air Inlet Heater
3056E Industrial Engine Electronic Control Module