Engine Water Pump - Inspect
A water pump that has failed might cause severe engine overheating. Severe engine overheating could result in the following problems:
- Cracks in the cylinder head
- Piston seizure
- Other potential engine damage
Show/hide table
Illustration 1 | g00851978 |
- Open the engine access door on the right side of the machine.
- Visually inspect the water pump for leaks. If leaks are found, all the seals must be replaced.
Show/hide table
Illustration 2 | g00591619 |
- Close the engine access door.
Note: See your Caterpillar dealer for further information and instructions for your machine.
Caterpillar Information System:
16H Motor Grader Engine Oil and Filter - Change
16H Motor Grader Engine Oil Sample - Obtain
CB-634D Vibratory Compactor Machine Systems Steering Frame Lock - Separate and Connect
570B Wheel Harvester and 580B Wheel Harvester Engine Supplement Refrigerant Compressor - Remove and Install
CB-634D Paving Compactor Engine Oil and Filter - Change
16H Motor Grader Engine Oil Level - Check
914G Compact Wheel Loader and IT14G Integrated Toolcarrier Transmission Electronic Control System Diagnostic Capabilities
CP-433E, CS-423E and CS-433E Paving Compactors Platform Tilting
CB-634D Paving Compactor Engine Oil Sample - Obtain
416D, 420D, 424D, 428D, 430D, 432D, 438D and 442D Backhoe Loaders Hydraulic and Steering System Control Valve (Tilt) (Mechanically Operated) - Single Tilt Machines
CB-634D Paving Compactor Engine Oil Level - Check
CB-634D Paving Compactor Engine Mounts - Inspect
CB-634D Vibratory Compactor Machine Systems Hydraulic System Pressure - Release
914G Compact Wheel Loader and IT14G Integrated Toolcarrier Transmission Electronic Control System Using the Diagnostic Indicator to Determine Diagnostic Codes
CB-634D Vibratory Compactor Machine Systems Battery and Battery Cable - Separate and Connect
CB-634D Paving Compactor Fuel System - Prime
C0.5, C0.7, C1.1/3011C, C1.5/3013C, C1.6 and C2.2/3024C/3024CT Industrial Engines and Engines for Caterpillar Built Machines Engine Oil Pressure - Test
416D Backhoe Loader Backhoe Stabilizer Controls
14H Motor Grader Ether Starting Aid Cylinder - Replace
CB-634D Paving Compactor Fuel System Secondary Filter - Replace
140H and 160H Motor Graders Electronic Unit Injector - Inspect/Adjust
CB-634D Paving Compactor Fuel System Water Separator - Drain
C0.5, C0.7, C1.1/3011C, C1.5/3013C, C1.6 and C2.2/3024C/3024CT Industrial Engines and Engines for Caterpillar Built Machines Cylinder Head - Inspect
CB-634D Paving Compactor Fuel Tank Cap and Strainer - Clean