Flywheel Housing
Show/hide table
 | |
| 图 1 | g00544711 |
按照如图所示的数字顺序拧紧螺栓。用标准的扭矩拧紧螺栓。
Show/hide table
 | |
| 图 2 | g00544712 |
(1) 轴承接头A的角度
(2) 轴承接头B的角度
轴承接头 A 与B之间的角度为15 ± 1 度。轴承接头角度为从飞轮壳垂直中心线处测量。
Show/hide table
 | |
| 图 3 | g00544717 |
A-A剖面图和B-B剖面图 | |
(3) 飞轮壳内轴承的内径 ... 57.201 ± 0.036 mm (2.2520 ± 0.0014 in)
(4) 飞轮壳端至轴承之间的距离 ... 0.8 - 0.8 mm (0.03 - 0.03 inch)
Show/hide table
 | |
| 图 4 | g01107082 |
(5) 两个螺栓的长度 ... 31.75 mm (1.250 inch)
(6) 两个螺栓的长度 ... 66.68 mm (2.625 inch)
飞轮壳螺栓的保留长度 ... 69.85 mm (2.750 inch)
Show/hide table
 | |
| 图 5 | g01107086 |
(7) 将 5P-3413 管用密封剂 涂到螺柱上并按拧紧至下列扭矩。 ... 35 ± 5 N·m (26 ± 4 lb ft)
(8) 安装前，将 5P-3413 管用密封剂 涂在注油塞的螺纹上。
注: 有关飞轮和飞轮壳的更多资料，参见 测试与调整, "中的基本气缸"
Caterpillar Information System:
836G Landfill Compactor and 834G Wheel Dozer Light Switches
550 Wheel Harvester, 570 Wheel Harvester and 580 Wheel Harvester Hydraulic System Solenoid Valve (Signal Cutoff)
784C and 785C Off-Highway Trucks Machine Systems Tire and Rim (Front) - Remove and Install
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0379 FMI 03 Pressure Sensor (Automatic Lubrication) Voltage Above Normal - Test
836G Landfill Compactor and 834G Wheel Dozer Differential Thrust Pin Clearance - Check
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0280 FMI 03 Temperature Sensor (Pump Drive) Voltage Above Normal - Test
IT14G Integrated Toolcarrier and 914G Wheel Loader Power Train Piston Pump (Hydrostatic)
CB-534C Vibratory Compactor Drum Scrapers - Inspect/Adjust/Replace
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0279 FMI 03 Temperature Sensor (Front Aftercooler Coolant) Voltage Above Normal - Test
836G Landfill Compactor and 834G Wheel Dozer Crankshaft Vibration Damper - Inspect
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0177 FMI 06 Temperature Sensor (Transmission Oil) Current Above Normal - Test
IT14G Integrated Toolcarrier and 914G Wheel Loader Standard Power Train General Information
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0425 FMI 03 Pressure Sensor (Front Brake Oil) Voltage Above Normal - Test
143H and 163H Motor Graders All Wheel Drive Service Record
980G Wheel Loader Power Train Transmission Hydraulic Control Valve - Assemble
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0426 FMI 03 Pressure Sensor (Rear Brake Oil) Voltage Above Normal - Test
550 Wheel Harvester, 570 Wheel Harvester and 580 Wheel Harvester Hydraulic System Pressure Reducing Valve (Color Marking System)
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0427 FMI 03 Temperature Sensor (Front Axle Oil) Voltage Above Normal - Test
IT14G Integrated Toolcarrier and 914G Wheel Loader Power Train Hydraulic Oil Filter
769D Off-Highway Truck and 771D Quarry Truck Engine Oil Level - Check
784C, 785C and 785C HAA Off-Highway Truck/Tractors Hydraulic System Hydraulic System Schematic
769D Off-Highway Truck and 771D Quarry Truck Engine Oil and Filter - Change
950G Series II Wheel Loader, 962G Series II Wheel Loader and IT62G Series II Integrated Toolcarrier Power Train Differential Backlash and Bearings - Adjust
769D Off-Highway Truck and 771D Quarry Truck Engine Valve Lash and Bridge - Check