Component Location
Show/hide table
| |
| 图 1 | g06048798 |
|
(1) 变矩器壳体
(2) M20x2.5 吊耳规定 (3) 带花键输入的变矩器 (4) 电子主安全阀 (eMRV) (5) 变矩器锁定阀 (6) 主行星齿轮壳体 (7) 机油加注管 (8) 行星齿轮壳体排油口 (9) 至变矩器的高压清洁机油管路 (10) 输出分动箱壳体 (11) 吊耳 (12) 熄火发动机牵引吸油管 (13) 可选的熄火发动机牵引机油回路机油泵 (14) 80% 流量回油管 (15) 辅助控制线束（可选） (16) 流向滤清器的高压机油 (17) 电磁阀歧管 (18) 滤清器压差传感器 (19) 电子离合器压力控制 (ECPC) 连接 (20) 吊耳 (21) 变速箱离合器阀 (22) 主变速箱机油泵 | |
Show/hide table
| |
| 图 2 | g06048885 |
|
(23) 机油滤清器
(24) 至变矩器的高压清洁机油管路 (25) 高压未过滤熄火发动机牵引机油管路 (26) 油位表 (27) 圆形输出配对法兰（SAE J1946“S 型”1810） (28) 20% 流量回油管 (29) 主机油吸油管 (30) 进口（来自机油冷却器的回油） (31) 供油温度传感器 (32) 通过端口向机油冷却器输油的变矩器安全阀 (33) 来自主泵的高压未过滤机油管路 | |
注: Caterpillar 变速箱使用液压诊断管接头进行制造、组装和测试。 检测系统压力时需使用快速分离连接器。 为方便用户和维修人员，快速分离连接器将保留在变速箱上。 除非另有说明，所有的快速分离连接器都符合 SAE-J1502 标准。
Caterpillar Information System:
CG137-08 and CG137-12 Industrial Engines Oxygen Level - Test
A New Fuel Priming Pump Is Used On Certain C175-16 Locomotive Engines {1258} A New Fuel Priming Pump Is Used On Certain C175-16 Locomotive Engines {1258}
XQP1100 Generator Set Engine Valve Lash - Check
XQP150 Rental Generator Set Walk-Around Inspection
TR35 Railway Transmission Maintenance Interval Schedule
TR35 Railway Transmission Transmission Oil Filter - Replace
Hose Inspection Form {0374, 0599, 5057, 5057} Hose Inspection Form {0374, 0599, 5057, 5057}
C175-20 Locomotive Engine Diesel Exhaust Fluid Pump - Inspect/Test
TR35 Railway Transmission Transmission Oil Sample - Obtain
TR35 Railway Transmission Transmission Oil Level - Check
3512C and 3516C Marine Auxiliary and Generator Set Engines Belts - Inspect/Adjust/Replace
TR35 Railway Transmission Transmission Oil - Change
XQP150 Rental Generator Set Belt Tensioner - Check - If Equipped
An Improved Cylinder Block Is Now Used for C7 Engines {1201} An Improved Cylinder Block Is Now Used for C7 Engines {1201}
XQP150 Rental Generator Set Coolant (ELC) - Change
TR35 Railway Transmission Specifications
C18 Generator Set Engines Gear Group (Front) - Remove and Install
TR35 Railway Transmission Plate Locations and Film Locations
C12.9 Marine Engines Supercharger - Remove and Install
3512E Land Electric Drive Air Shutoff - Test
A New Heat Exchanger Frame Is Now Used on Certain C18 Marine Engines {1379} A New Heat Exchanger Frame Is Now Used on Certain C18 Marine Engines {1379}
TA22 OEM Transmission General Information
G3512 Generator Set Engines Sensor Calibration Required - Test
TA22 OEM Transmission Service Tools