Camshaft Drive Gear - Remove
Show/hide table
所需工具 | |||
工具 | 零件号 | 零件描述 | 数量 |
A | 6V-6080 | 扭矩倍增器 | 1 |
5P-1748 | 套筒 | 1 |
- 拆下螺栓 (1)、螺栓 (2)、螺栓 (4) 和盖 (3)。
- 断开转速传感器 (5)。
Show/hide table
图 2 g03858298 - 拆下壳体 (6)、螺栓 (7)、转速正时轮 (8) 和隔套 (9)。
Show/hide table
图 3 g03858437 - 从曲轴和凸轮轴上卸下正时销。
- 使用工具 (A) 拆下螺栓 (13) 和垫圈 (14)。
注: 松开螺栓 (13) 时,锁止手动盘车总成以防止发动机旋转。
- 拆下螺栓 (11) 和板 (12)。
- 将垫圈 (14) 置于凸轮轴和板 (12) 之间,然后安装螺栓 (13)。
注: 确保安装螺栓 (13),以固定凸轮轴主动齿轮 (10),同时脱开凸轮轴的锥面。
- 均匀拧紧螺栓 (11),以便将凸轮轴主动齿轮 (10) 脱开凸轮轴锥面。
- 将适当的起吊设备连接在凸轮轴驱动齿轮 (10) 上。 凸轮轴主动齿轮的重量约为
41 kg (90 lb) 。 - 拆下螺栓 (11)、螺栓 (13)、板 (12)、垫圈 (14) 和凸轮轴主动齿轮 (10)。
Show/hide table
图 1 | g03858195 |
Caterpillar Information System:
New Fuel Lines and Mounting Hardware Installation On Certain 3500 Engines{1252, 1274} New Fuel Lines and Mounting Hardware Installation On Certain 3500 Engines{1252, 1274}
120 and 120 AWD Motor Grader Brake Accumulator - Check
120 and 120 AWD Motor Grader Lubricant Viscosities - Fluids Recommendations
120 and 120 AWD Motor Grader Capacities (Refill)
3512C Generator Set Engine Radiator Core - Remove and Install
C8.7 Marine Engine Engine Oil Pan - Remove and Install
Cat® Command For Hauling MID 039 - CID 3710 - FMI 19
Cat® Command For Hauling MID 039 - CID 3710 - FMI 02
3516C and C175-16 Engines Selective Catalytic Reduction Cat ET Service Features
G3306B Generator Set Maintenance Interval Schedule - Turbocharged
3512C Generator Set Engine Radiator Group - Remove and Install
G3606 and G3608 Engines Crankshaft Rear Seal - Remove and Install
120 and 120 AWD Motor Grader Battery Disconnect Switch
120 and 120 AWD Motor Grader Engine Oil Level - Check
Improved Alternator Mounting Groups Are Used for Certain C15 and C18 Industrial, Marine, and Petroleum Engines {1405} Improved Alternator Mounting Groups Are Used for Certain C15 and C18 Industrial, Marine, and Petroleum Engines {1405}
2015/07/07 A New Charging Alternator Is Used on Certain 3412C, C27, and C32 Commercial Engines {1405}
323F LN Excavator Machine Systems Operational Checks
2015/07/07 Improved Flow Limiters Are Used in Certain C175 Commercial Engines {1288}
323F SA Excavator and 323F MHPU Machine Systems Engine Performance - Test - Engine Speed
323F LN Excavator Machine Systems Swing Speed and Overswing on Level Ground - Check
352F Excavator Maintenance Interval Schedule
120 and 120 AWD Motor Grader Engine Oil and Filter - Change
120 and 120 AWD Motor Grader Transmission and Differential Oil - Change
120 and 120 AWD Motor Grader Transmission and Differential Oil Filter and Screens - Replace/Clean