Electrohydraulic System - Inspect
检查电液系统的这些项目状况:
- 机油油位
- 软管、管路、连接和部件
Show/hide table
图 1 | g03761738 |
(1) 目测表 (2) 软管 (3) 管路 |
检查机油油位
- 检查目测表 (1) 内的油位。
油位应介于标注在油箱上的 "ADD(加)"和 "FULL(满)"标记之间。
- 如果需要,卸下机油加注口盖。 将正确的机油加入机油加注口。
注: 有关机油容量,参考此操作和保养手册, "加注容量"。
注: 关于要使用的正确机油,参考本操作和保养手册, "油液建议"。
- 清洁机油滤清器加注口盖。 安装机油滤清器加注口盖。
检查管路、连接和部件
Show/hide table
连杆机构能移动并产生挤压点其将造成人员受伤。 将手从联杆机构拿开。 |
检查软管和管路是否有磨损或泄漏。 确保软管和管路夹紧适当。 检查连接处是否渗漏。 确保连接牢固可靠。
检查下列项目是否有泄漏或状态良好。
- 执行器
- 压力安全阀
- 油泵
如有必要,进行维修。
Caterpillar Information System:
G3600 A4 Engines Electrohydraulic Actuator - Recondition
G3600 A4 Engines Engine Operation
G3600 A4 Engines Configuration Parameters
G3600 A4 Engines Monitoring System
G3600 A4 Engines Control Panel
C13 Generator Set Engine Engine Oil Filter Base - Remove and Install
C7.1 Engines DEF Module Does Not Respond
C7.1 Engines DEF Does Not Purge
C7.1 Engines DEF Control Module Temperature Is High
2014/12/24 Revision to "Reports and Messages Not Available" Troubleshooting Procedure for Cat® Products with Cat® Product Link 121/321 {7606}
3512C and 3516C Engines Maintenance Interval Schedule - Prime Power
C13 Generator Set Engine Air Inlet Elbow - Remove and Install
C13 Generator Set Engine Engine Oil Cooler - Remove and Install
G3600 A4 Engines Electrohydraulic System Oil - Change
G3600 A4 Engines Electrohydraulic System Oil Filter - Change
C13 Generator Set Engine Engine Oil Pump - Remove and Install
C15 and C18 Engines Maintenance Interval Schedule - C15 Engines With Ratings Greater Than 579 hp
C15 and C18 Engines Maintenance Interval Schedule - C15 Engines
C15 and C18 Engines Maintenance Interval Schedule - C18 Engines
C15 and C18 Engines Maintenance Interval Schedule - C18 Engines With Ratings Greater Than 760 HP
C32 Marine Engines Auxiliary Water Pump - Disassemble
C7.1 Engines DEF Pressure Is Low
2014/11/26 New Electrical Schematic Is Available for Certain Retrofit Aftertreatment Selective Catalytic Reduction Systems {108F, 1091, 7566}
2015/02/27 A New Procedure Exists for Marking Diesel Particulate Filters that Are Being Returned to Cat ® Reman {108F, 7754}