Diagnostic Trouble Codes
Table 1 lists the diagnostic trouble codes that apply to the engines that are covered in this manual. Use the Caterpillar Electronic Technician (ET) to determine the codes that are active or logged. Then refer to the appropriate troubleshooting procedure for more information.
Note: A requirement for all troubleshooting is that the troubleshooting is based on active and/or passive diagnostic trouble codes. Do not troubleshoot based on flash codes alone.
Portions of this material are reprinted with permission from SAE J1939DA_201607© 2016 SAE International, SAE International is not responsible for any use or translation of this material, in whole or in part. Please contact SAE International to obtain a complete copy of SAE J1939DA_201607, the official definitive source of this standard.
Show/hide table
| List of Diagnostic Trouble Codes | ||
| J1939 Code and Description | CDL Code and Description | Troubleshooting Procedure |
| N/A | 486-3
Engine Fan Reverse Switch : Voltage Above Normal |
Refer to the Machine Troubleshooting Guide |
| N/A | 486-4
Engine Fan Reverse Switch : Voltage Below Normal |
Refer to the Machine Troubleshooting Guide |
| N/A | 544-2
Engine Cooling Fan Speed Sensor : Erratic, Intermittent, or Incorrect |
Troubleshooting, "Cooling Fan Speed - Test" |
| N/A | 544-8
Engine Cooling Fan Speed Sensor : Abnormal Frequency, Pulse Width, or Period |
Troubleshooting, "Cooling Fan Speed - Test" |
| N/A | 1076-5
Engine Cooling Fan Bypass Solenoid : Current Below Normal |
Troubleshooting, "Cooling Fan Control - Test" |
| N/A | 1076-6
Engine Cooling Fan Bypass Solenoid : Current Above Normal |
Troubleshooting, "Cooling Fan Control - Test" |
| N/A | 1937-2
Engine Coolant Flow Switch : Erratic, Intermittent, or Incorrect |
Troubleshooting, "Sensor Signal (Analog, Passive) - Test" |
| 29-2
Accelerator Pedal Position 2 : Erratic, Intermittent, or Incorrect |
774-2
Secondary Throttle Position Sensor: Erratic, Intermittent, or Incorrect |
Troubleshooting, "Speed Control - Test" |
| 29-3
Accelerator Pedal Position 2 : Voltage Above Normal |
774-3
Secondary Throttle Position Sensor: Voltage Above Normal |
Troubleshooting, "Speed Control - Test" |
| 29-4
Accelerator Pedal Position 2 : Voltage Below Normal |
774-4
Secondary Throttle Position Sensor: Voltage Below Normal |
Troubleshooting, "Speed Control - Test" |
| 29-8
Accelerator Pedal Position 2 : Abnormal Frequency, Pulse Width, or Period |
774-8
Secondary Throttle Position Sensor: Abnormal Frequency, Pulse Width, or Period |
Troubleshooting, "Speed Control - Test" |
| 91-2
Accelerator Pedal Position 1 : Erratic, Intermittent, or Incorrect |
91-2
Throttle Position Sensor : Erratic, Intermittent, or Incorrect |
Troubleshooting, "Speed Control - Test" |
| 91-3
Accelerator Pedal Position 1 : Voltage Above Normal |
91-3
Throttle Position Sensor : Voltage Above Normal |
Troubleshooting, "Speed Control - Test" |
| 91-4
Accelerator Pedal Position 1 : Voltage Below Normal |
91-4
Throttle Position Sensor : Voltage Below Normal |
Troubleshooting, "Speed Control - Test" |
| 91-8
Accelerator Pedal Position 1 : Abnormal Frequency, Pulse Width, or Period |
91-8
Throttle Position Sensor : Abnormal Frequency, Pulse Width, or Period |
Troubleshooting, "Speed Control - Test" |
| 97-3
Water In Fuel Indicator : Voltage Above Normal |
3547-3
Water in Fuel System Switch : Voltage Above Normal |
Troubleshooting, "Water in Fuel - Test" |
| 100-3
Engine Oil Pressure : Voltage Above Normal |
100-3
Engine Oil Pressure Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 100-4
Engine Oil Pressure : Voltage Below Normal |
100-4
Engine Oil Pressure Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 101-3
Engine Crankcase Pressure : Voltage Above Normal |
101-3
Crankcase Air Pressure Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 101-4
Engine Crankcase Pressure : Voltage Below Normal |
101-4
Crankcase Air Pressure Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 101-13
Engine Crankcase Pressure : Calibration Required |
101-13
Crankcase Air Pressure Sensor : Calibration Required |
Troubleshooting, "Sensor Calibration Required - Test" |
| 108-3
Barometric Pressure : Voltage Above Normal |
3528-3
Atmospheric Pressure Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 108-4
Barometric Pressure : Voltage Below Normal |
3528-4
Atmospheric Pressure Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 108-21
Barometric Pressure : Calibration Required |
3528-21
Atmospheric Pressure Sensor : Calibration Required |
Troubleshooting, "Sensor Supply - Test" |
| 109-3
Engine Coolant Pressure : Voltage Above Normal |
2302-3
Engine Coolant Pump Outlet Pressure Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 109-4
Engine Coolant Pressure : Voltage Below Normal |
2302-4
Engine Coolant Pump Outlet Pressure Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 110-3
Engine Coolant Temperature : Voltage Above Normal |
110-3
Engine Coolant Temperature Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Passive) - Test" |
| 110-4
Engine Coolant Temperature : Voltage Below Normal |
110-4
Engine Coolant Temperature Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Passive) - Test" |
| 157-3
Engine Injector Metering Rail #1 Pressure : Voltage Above Normal |
1797-3
Fuel Rail Pressure Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 157-4
Engine Injector Metering Rail #1 Pressure : Voltage Below Normal |
1797-4
Fuel Rail Pressure Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 168-3
Battery Potential / Power Input 1 : Voltage Above Normal |
168-3
Electrical System Voltage : Voltage Above Normal |
Troubleshooting, "Electrical Power Supply - Test" |
| 168-4
Battery Potential / Power Input 1 : Voltage Below Normal |
168-4
Electrical System Voltage : Voltage Below Normal |
Troubleshooting, "Electrical Power Supply - Test" |
| 171-3
Ambient Air Temperature : Voltage Above Normal |
171-3
Ambient Air Temperature Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Passive) - Test" |
| 171-4
Ambient Air Temperature : Voltage Below Normal |
171-4
Ambient Air Temperature Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Passive) - Test" |
| 172-3
Engine Air Inlet Temperature : Voltage Above Normal |
2526-3
Air Inlet Temperature Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Passive) - Test" |
| 172-4
Engine Air Inlet Temperature : Voltage Below Normal |
2526-4
Air Inlet Temperature Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Passive) - Test" |
| 174-3
Engine Fuel Temperature 1 : Voltage Above Normal |
174-3
Fuel Temperature Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Passive) - Test" |
| 174-4
Engine Fuel Temperature 1 : Voltage Below Normal |
174-4
Fuel Temperature Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Passive) - Test" |
| 175-3
Engine Oil Temperature 1 : Voltage Above Normal |
175-3
Engine Oil Temperature 1 : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Passive) - Test" |
| 175-4
Engine Oil Temperature 1 : Voltage Below Normal |
175-4
Engine Oil Temperature 1 : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Passive) - Test" |
| 190-8
Engine Speed : Abnormal Frequency, Pulse Width, or Period |
190-8
Engine Speed Sensor : Abnormal Frequency, Pulse Width, or Period |
Troubleshooting, "Speed/Timing - Test" |
| 411-3
Engine Exhaust Gas Recirculation Differential Pressure : Voltage Above Normal |
3387-3
EGR Differential Pressure Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 411-4
Engine Exhaust Gas Recirculation Differential Pressure : Voltage Below Normal |
3387-4
EGR Differential Pressure Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 411-13
Engine Exhaust Gas Recirculation Differential Pressure : Calibration Required |
3387-13
EGR Differential Pressure Sensor : Calibration Required |
Troubleshooting, "Sensor Calibration Required - Test" |
| 412-3
Engine Exhaust Gas Recirculation Temperature : Voltage Above Normal |
3386-3
EGR Temperature Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Passive) - Test" |
| 412-4
Engine Exhaust Gas Recirculation Temperature : Voltage Below Normal |
3386-4
EGR Temperature Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Passive) - Test" |
| 441-3
Auxiliary Temperature #1 : Voltage Above Normal |
1836-3
Auxiliary Temperature Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 441-4
Auxiliary Temperature #1 : Voltage Below Normal |
1836-4
Auxiliary Temperature Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 442-3
Auxiliary Temperature #2 : Voltage Above Normal |
3683-3
Auxiliary Temperature Sensor #2 : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Passive) - Test" |
| 442-4
Auxiliary Temperature #2 : Voltage Below Normal |
3683-4
Auxiliary Temperature Sensor #2 : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Passive) - Test" |
| 597-3
Brake Switch : Voltage Above Normal |
298-3
Service Brake Pedal Switch : Voltage Above Normal |
Refer to the Machine Troubleshooting Guide |
| 597-4
Brake Switch : Voltage Below Normal |
298-4
Service Brake Pedal Switch : Voltage Below Normal |
Refer to the Machine Troubleshooting Guide |
| 625-14
Proprietary Data Link : Special Instruction |
246-14
Proprietary CAN Data Link: Special Instruction |
Troubleshooting, "Data Link Configuration Status - Test" |
| 626-5
Engine Start Enable Device 1 : Current Below Normal |
2417-5
Ether Injection Control Solenoid : Current Below Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 626-6
Engine Start Enable Device 1 : Current Above Normal |
2417-6
Ether Injection Control Solenoid : Current Above Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 630-2
Calibration Memory : Erratic, Intermittent, or Incorrect |
268-2
Programmed Parameter Fault : Erratic, Intermittent, or Incorrect |
Troubleshooting, "Configuration Parameters" |
| 631-2
Calibration Module : Erratic, Intermittent, or Incorrect |
253-2
Personality Module : Erratic, Intermittent, or Incorrect |
Troubleshooting, "ECM Software - Install" |
| 637-11
Engine Timing Sensor : Other Failure Mode |
261-11
Engine Timing Offset fault |
Troubleshooting, "Timing - Calibrate" |
| 637-13
Engine Timing Sensor : Calibration Required |
261-13
Engine Timing Calibration : Calibration Required |
Troubleshooting, "Timing - Calibrate" |
| 639-9
J1939 Network #1 : Abnormal Update Rate |
247-9
SAE J1939 Data Link : Abnormal Update Rate |
Troubleshooting, "Data Link - Test" |
| 639-14
J1939 Network #1 : Special Instruction |
247-14
SAE J1939 Data Link : Special Instruction |
Troubleshooting, "Data Link - Test" |
| 651-2
Engine Injector Cylinder #01 : Erratic, Intermittent, or Incorrect |
1-2
Cylinder #1 Injector : Erratic, Intermittent, or Incorrect |
Troubleshooting, "Injector Solenoid - Test" |
| 651-5
Engine Injector Cylinder #01 : Current Below Normal |
1-5
Cylinder #1 Injector : Current Below Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 651-6
Engine Injector Cylinder #01 : Current Above Normal |
1-6
Cylinder #1 Injector : Current Above Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 651-7
Engine Injector Cylinder #01 : Not Responding Properly |
1-7
Cylinder #1 Injector : Not Responding Properly |
Troubleshooting, "Injector Solenoid - Test" |
| 652-2
Engine Injector Cylinder #02 : Erratic, Intermittent, or Incorrect |
2-2
Cylinder #2 Injector : Erratic, Intermittent, or Incorrect |
Troubleshooting, "Injector Solenoid - Test" |
| 652-5
Engine Injector Cylinder #02 : Current Below Normal |
2-5
Cylinder #2 Injector : Current Below Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 652-6
Engine Injector Cylinder #02 : Current Above Normal |
2-6
Cylinder #2 Injector : Current Above Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 652-7
Engine Injector Cylinder #02 : Not Responding Properly |
2-7
Cylinder #2 Injector : Not Responding Properly |
Troubleshooting, "Injector Solenoid - Test" |
| 653-2
Engine Injector Cylinder #03 : Erratic, Intermittent, or Incorrect |
3-2
Cylinder #3 Injector : Erratic, Intermittent, or Incorrect |
Troubleshooting, "Injector Solenoid - Test" |
| 653-5
Engine Injector Cylinder #03 : Current Below Normal |
3-5
Cylinder #3 Injector : Current Below Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 653-6
Engine Injector Cylinder #03 : Current Above Normal |
3-6
Cylinder #3 Injector : Current Above Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 653-7
Engine Injector Cylinder #03 : Not Responding Properly |
3-7
Cylinder #3 Injector : Not Responding Properly |
Troubleshooting, "Injector Solenoid - Test" |
| 654-2
Engine Injector Cylinder #04 : Erratic, Intermittent, or Incorrect |
4-2
Cylinder #4 Injector : Erratic, Intermittent, or Incorrect |
Troubleshooting, "Injector Solenoid - Test" |
| 654-5
Engine Injector Cylinder #04 : Current Below Normal |
4-5
Cylinder #4 Injector : Current Below Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 654-6
Engine Injector Cylinder #04 : Current Above Normal |
4-6
Cylinder #4 Injector : Current Above Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 654-7
Engine Injector Cylinder #04 : Not Responding Properly |
4-7
Cylinder #4 Injector : Not Responding Properly |
Troubleshooting, "Injector Solenoid - Test" |
| 655-2
Engine Injector Cylinder #05 : Erratic, Intermittent, or Incorrect |
5-2
Cylinder #5 Injector : Erratic, Intermittent, or Incorrect |
Troubleshooting, "Injector Solenoid - Test" |
| 655-5
Engine Injector Cylinder #05 : Current Below Normal |
5-5
Cylinder #5 Injector : Current Below Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 655-6
Engine Injector Cylinder #05 : Current Above Normal |
5-6
Cylinder #5 Injector : Current Above Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 655-7
Engine Injector Cylinder #05 : Not Responding Properly |
5-7
Cylinder #5 Injector : Not Responding Properly |
Troubleshooting, "Injector Solenoid - Test" |
| 656-2
Engine Injector Cylinder #06 : Erratic, Intermittent, or Incorrect |
6-2
Cylinder #6 Injector : Erratic, Intermittent, or Incorrect |
Troubleshooting, "Injector Solenoid - Test" |
| 656-5
Engine Injector Cylinder #06 : Current Below Normal |
6-5
Cylinder #6 Injector : Current Below Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 656-6
Engine Injector Cylinder #06 : Current Above Normal |
6-6
Cylinder #6 Injector : Current Above Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 656-7
Engine Injector Cylinder #06 : Not Responding Properly |
6-7
Cylinder #6 Injector : Not Responding Properly |
Troubleshooting, "Injector Solenoid - Test" |
| 677-5
Engine Starter Motor Relay : Current Below Normal |
444-5
Starter Motor Relay : Current Below Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 677-6
Engine Starter Motor Relay : Current Above Normal |
444-6
Starter Motor Relay : Current Above Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 678-3
ECU 8 Volts DC Supply : Voltage Above Normal |
41-3
8 Volt DC Supply : Voltage Above Normal |
Troubleshooting, "Sensor Supply - Test" |
| 678-4
ECU 8 Volts DC Supply : Voltage Below Normal |
41-4
8 Volt DC Supply : Voltage Below Normal |
Troubleshooting, "Sensor Supply - Test" |
| 723-8
Engine Speed Sensor #2 : Abnormal Frequency, Pulse Width, or Period |
342-8
Secondary Engine Speed Sensor : Abnormal Frequency, Pulse Width, or Period |
Troubleshooting, "Speed/Timing - Test" |
| 1074-5
Engine (Exhaust) Brake Output : Current Below Normal |
2232-5
Engine Retarder Solenoid : Current Below Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 1074-6
Engine (Exhaust) Brake Output : Current Above Normal |
2232-6
Engine Retarder Solenoid : Current Above Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 1176-3
Engine Turbocharger 1 Compressor Inlet Pressure : Voltage Above Normal |
2738-3
Turbocharger #1 Compressor Inlet Pressure Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 1176-4
Engine Turbocharger 1 Compressor Inlet Pressure : Voltage Below Normal |
2738-4
Turbocharger #1 Compressor Inlet Pressure Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 1231-9
J1939 Network #2 : Abnormal Update Rate |
2348-9
SAE J1939 Data Link #2 : Abnormal Update Rate |
Troubleshooting, "Data Link - Test" |
| 1231-14
J1939 Network #2 : Special Instruction |
2348-14
SAE J1939 Data Link #2 : Special Instruction |
Troubleshooting, "Data Link - Test" |
| 1235-9
J1939 Network #3 : Abnormal Update Rate |
5856-9
SAE J1939 Data Link #3:Abnormal Update Rate |
Troubleshooting, "Data Link - Test" |
| 1235-14
J1939 Network #3 : Special Instruction |
5856-14
SAE J1939 Data Link #3: Special Instruction |
Troubleshooting, "Data Link - Test" |
| 1347-5
Engine Fuel Pump Pressurizing Assembly #1 : Current Below Normal |
1779-5
Fuel Rail #1 Pressure Valve Solenoid : Current Below Normal |
Troubleshooting, "Fuel Injection Pump - Test" |
| 1347-6
Engine Fuel Pump Pressurizing Assembly #1 : Current Above Normal |
1779-6
Fuel Rail #1 Pressure Valve Solenoid : Current Above Normal |
Troubleshooting, "Fuel Injection Pump - Test" |
| 1348-5
Engine Fuel Pump Pressurizing Assembly #2 : Current Below Normal |
1780-5
Fuel Rail #2 Pressure Valve Solenoid : Current Below Normal |
Troubleshooting, "Fuel Injection Pump - Test" |
| 1348-6
Engine Fuel Pump Pressurizing Assembly #2 : Current Above Normal |
1780-6
Fuel Rail #2 Pressure Valve Solenoid : Current Above Normal |
Troubleshooting, "Fuel Injection Pump - Test" |
| 1385-3
Auxiliary Temperature #1 : Voltage Above Normal |
1836-3
Auxiliary Temperature Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Passive) - Test" |
| 1385-4
Auxiliary Temperature #1 : Voltage Below Normal |
1836-4
Auxiliary Temperature Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Passive) - Test" |
| 1387-3
Auxiliary Pressure #1 : Voltage Above Normal |
1835-3
Auxiliary Pressure Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 1387-4
Auxiliary Pressure #1 : Voltage Below Normal |
1835-4
Auxiliary Pressure Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 1761-3
Aftertreatment 1 Diesel Exhaust Fluid Tank Level : Voltage Above Normal |
3130-3
Aftertreatment #1 SCR Catalyst Reagent Tank #1 Level Sensor : Voltage Above Normal |
Troubleshooting, "DEF Tank Sensor - Test" |
| 1761-4
Aftertreatment 1 Diesel Exhaust Fluid Tank Level : Voltage Below Normal |
3130-4
Aftertreatment #1 SCR Catalyst Reagent Tank #1 Level Sensor : Voltage Below Normal |
Troubleshooting, "DEF Tank Sensor - Test" |
| 2630-3
Engine Charge Air Cooler Outlet Temperature : Voltage Above Normal |
3372-3
Engine Charge Air Cooler #1 Outlet Temperature Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Passive) - Test" |
| 2630-4
Engine Charge Air Cooler Outlet Temperature : Voltage Below Normal |
3372-4
Engine Charge Air Cooler #1 Outlet Temperature Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Passive) - Test" |
| 2791-5
Engine Exhaust Gas Recirculation (EGR) Valve Control : Current Below Normal |
3405-5
EGR Valve Control : Current Below Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 2791-6
Engine Exhaust Gas Recirculation (EGR) Valve Control : Current Above Normal |
3405-6
EGR Valve Control : Current Above Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 2813-5
Engine Air Shutoff Command Status : Current Below Normal |
3239-5
Air Shutoff Relay : Current Below Normal |
Troubleshooting, "Air Shutoff - Test" |
| 2813-6
Engine Air Shutoff Command Status : Current Above Normal |
3239-6
Air Shutoff Relay : Current Above Normal |
Troubleshooting, "Air Shutoff - Test" |
| 2853-9
Communications Connection : Abnormal Update Rate |
N/A | Troubleshooting, "Data Link - Test" |
| 3031-3
Aftertreatment 1 Diesel Exhaust Fluid Tank Temperature : Voltage Above Normal |
3134-3
Aftertreatment #1 SCR Catalyst Reagent Tank #1 Temperature Sensor : Voltage Above Normal |
Troubleshooting, "DEF Tank Sensor - Test" |
| 3031-4
Aftertreatment 1 Diesel Exhaust Fluid Tank Temperature : Voltage Below Normal |
3134-4
Aftertreatment #1 SCR Catalyst Reagent Tank #1 Temperature Sensor : Voltage Below Normal |
Troubleshooting, "DEF Tank Sensor - Test" |
| 3216-11
Aftertreatment #1 Intake NOx : Other Failure Mode |
3655-11
Aftertreatment #1 Intake NOx Level Sensor : Other Failure Mode |
Troubleshooting, "Sensor (Data Link Type) - Test" |
| 3216-12
Aftertreatment #1 Intake NOx : Failure |
3655-12
Aftertreatment #1 Intake NOx Level Sensor : Failure |
Troubleshooting, "Sensor (Data Link Type) - Test" |
| 3226-11
Aftertreatment #1 Outlet NOx : Other Failure Mode |
3609-11
Aftertreatment #1 Outlet #1 NOx Level Sensor : Other Failure Mode |
Troubleshooting, "Sensor (Data Link Type) - Test" |
| 3226-12
Aftertreatment #1 Outlet NOx : Failure |
3609-12
Aftertreatment #1 Outlet #1 NOx Level Sensor : Failure |
Troubleshooting, "Sensor (Data Link Type) - Test" |
| 3241-3
Exhaust Gas Temperature 1 : Voltage Above Normal |
3485-3
Aftertreatment #1 Exhaust Gas Temperature #1 Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 3241-4
Exhaust Gas Temperature 1 : Voltage Below Normal |
3485-4
Aftertreatment #1 Exhaust Gas Temperature #1 Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 3242-3
Particulate Trap Intake Gas Temperature : Voltage Above Normal |
2452-3
DPF #1 Intake Temperature Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 3242-4
Particulate Trap Intake Gas Temperature : Voltage Below Normal |
2452-4
DPF #1 Intake Temperature Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 3251-2
Particulate Trap Differential Pressure : Erratic, Intermittent, or Incorrect |
2458-2
DPF #1 Differential Pressure Sensor : Erratic, Intermittent, or Incorrect |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 3251-3
Particulate Trap Differential Pressure : Voltage Above Normal |
2458-3
DPF #1 Differential Pressure Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 3251-4
Particulate Trap Differential Pressure : Voltage Below Normal |
2458-4
DPF #1 Differential Pressure Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 3251-13
Particulate Trap Differential Pressure : Out of Calibration |
2458-13
DPF #1 Differential Pressure Sensor : Out of Calibration |
Troubleshooting, "Sensor Calibration Required - Test" |
| 3358-3
Engine Exhaust Gas Recirculation Inlet Pressure : Voltage Above Normal |
3385-3
EGR Intake Pressure Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 3358-4
Engine Exhaust Gas Recirculation Inlet Pressure : Voltage Below Normal |
3385-4
EGR Intake Pressure Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 3358-13
Engine Exhaust Gas Recirculation Inlet Pressure : Calibration Required |
3385-13
EGR Intake Pressure Sensor : Calibration Required |
Troubleshooting, "Sensor Calibration Required - Test" |
| 3358-21
Engine Exhaust Gas Recirculation Inlet Pressure : Data Drifted Low |
3385-21
EGR Intake Pressure Sensor : Data Drifted Low |
Troubleshooting, "Sensor Supply - Test" |
| 3360-3
Aftertreatment 1 Diesel Exhaust Fluid Controller : Voltage Above Normal |
3820-3
Aftertreatment #1 Diesel Exhaust Fluid Controller : Voltage Above Normal |
Troubleshooting, "Electrical Power Supply - Test" |
| 3360-4
Aftertreatment 1 Diesel Exhaust Fluid Controller : Voltage Below Normal |
3820-4
Aftertreatment #1 Diesel Exhaust Fluid Controller : Voltage Below Normal |
Troubleshooting, "Electrical Power Supply - Test" |
| 3360-9
Aftertreatment #1 DEF Controller : Abnormal Update Rate |
3820-9
Aftertreatment #1 Diesel Exhaust Fluid Controller : Abnormal Update Rate |
Troubleshooting, "Data Link - Test" |
| 3360-12
Aftertreatment 1 Diesel Exhaust Fluid Controller : Failure |
3820-12
Aftertreatment #1 Diesel Exhaust Fluid Controller : Failure |
Troubleshooting, "Sensor (Data Link Type) - Test" |
| 3361-5
Catalyst Dosing Unit : Current Below Normal |
3821-5
Aftertreatment #1 Diesel Exhaust Fluid Dosing Valve Actuator : Current Below Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 3361-6
Catalyst Dosing Unit : Current Above Normal |
3821-6
Aftertreatment #1 Diesel Exhaust Fluid Dosing Valve Actuator : Current Above Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 3361-7
Catalyst Dosing Unit : Not Responding Properly |
3821-7
Aftertreatment #1 Diesel Exhaust Fluid Dosing Valve Actuator : Not Responding Properly |
Troubleshooting, "DEF Module Does Not Respond" |
| 3361-11
Catalyst Dosing Unit : Other Failure Mode |
3821-11
Aftertreatment #1 Diesel Exhaust Fluid Dosing Valve Actuator : Other Failure Mode |
Troubleshooting, "DEF Module Does Not Respond" |
| 3361-14
Catalyst Dosing Unit : Special Instruction |
3821-14
Aftertreatment #1 Diesel Exhaust Fluid Dosing Valve Actuator : Special Instruction |
Troubleshooting, "DEF Module Does Not Respond" |
| 3363-5
Aftertreatment 1 Diesel Exhaust Fluid Tank Heater : Current Below Normal |
3126-5
Aftertreatment #1 SCR Catalyst Reagent Tank #1 Heater Coolant Diverter Solenoid : Current Below Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 3363-6
Aftertreatment 1 Diesel Exhaust Fluid Tank Heater : Current Above Normal |
3126-6
Aftertreatment #1 SCR Catalyst Reagent Tank #1 Heater Coolant Diverter Solenoid : Current Above Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 3363-7
Aftertreatment 1 Diesel Exhaust Fluid Tank Heater : Not Responding Properly |
3126-7
Aftertreatment #1 SCR Catalyst Reagent Tank #1 Heater Coolant Diverter Solenoid : Not Responding Properly |
Troubleshooting, "DEF Temperature Is Low" |
| 3479-5
Aftertreatment #1 Fuel Pressure Control : Current Below Normal |
2461-5
ARD Fuel Pressure #1 Control : Current Below Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 3479-6
Aftertreatment #1 Fuel Pressure Control : Current Above Normal |
2461-6
ARD Fuel Pressure #1 Control : Current Above Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 3480-3
Aftertreatment #1 Fuel Pressure #1 : Voltage Above Normal |
2460-3
ARD Fuel Pressure #1 Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 3480-4
Aftertreatment #1 Fuel Pressure #1 : Voltage Below Normal |
2460-4
ARD Fuel Pressure #1 Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 3484-5
Aftertreatment #1 Ignition : Current Below Normal |
2465-5
Aftertreatment #1 Ignition Transformer Primary : Current Below Normal |
Troubleshooting, "ARD Ignition - Test" |
| 3484-6
Aftertreatment #1 Ignition : Current Above Normal |
2465-6
Aftertreatment #1 Ignition Transformer Primary : Current Above Normal |
Troubleshooting, "ARD Ignition - Test" |
| 3487-5
Aftertreatment #1 Air Pressure Control : Current Below Normal |
2489-5
ARD Air Pressure Control Actuator : Current Below Normal |
Troubleshooting, "ARD Combustion Air - Test" |
| 3487-6
Aftertreatment #1 Air Pressure Control : Current Above Normal |
2489-6
ARD Air Pressure Control Actuator : Current Above Normal |
Troubleshooting, "ARD Combustion Air - Test" |
| 3487-13
Aftertreatment #1 Air Pressure Control : Out of Calibration |
2489-13
ARD Air Pressure Control Actuator : Out of Calibration |
Troubleshooting, "ARD Combustion Air Valve - Replace" |
| 3488-3
Aftertreatment #1 Air Pressure Actuator Position : Voltage Above Normal |
2490-3
ARD Air Pressure Control Actuator Position Sensor : Voltage Above Normal |
Troubleshooting, "ARD Combustion Air - Test" |
| 3488-4
Aftertreatment #1 Air Pressure Actuator Position : Voltage Below Normal |
2490-4
ARD Air Pressure Control Actuator Position Sensor : Voltage Below Normal |
Troubleshooting, "ARD Combustion Air - Test" |
| 3509-3
Sensor Supply Voltage 1 : Voltage Above Normal |
262-3
5 Volt Sensor DC Power Supply : Voltage Above Normal |
Troubleshooting, "Sensor Supply - Test" |
| 3509-4
Sensor Supply Voltage 1 : Voltage Below Normal |
262-4
5 Volt Sensor DC Power Supply : Voltage Below Normal |
Troubleshooting, "Sensor Supply - Test" |
| 3510-3
Sensor Supply Voltage 2 : Voltage Above Normal |
2131-3
5 Volt Sensor DC Power Supply #2 : Voltage Above Normal |
Troubleshooting, "Sensor Supply - Test" |
| 3510-4
Sensor Supply Voltage 2 : Voltage Below Normal |
2131-4
5 Volt Sensor DC Power Supply #2 : Voltage Below Normal |
Troubleshooting, "Sensor Supply - Test" |
| 3511-11
Sensor Supply Voltage 3 : Other Failure Mode |
3482-11
Sensor Supply #3 : Other Failure Mode |
Troubleshooting, "DEF Pump Sensor Supply - Test" |
| 3516-12
Catalyst Reagent Concentration : Failure |
3100-12
Aftertreatment #1 SCR Catalyst Tank Reagent Quality Sensor : Failure |
Troubleshooting, "Sensor (Data Link Type) - Test" |
| 3563-3
Engine Intake Manifold #1 Absolute Pressure : Voltage Above Normal |
1785-3
Intake Manifold Pressure Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 3563-4
Engine Intake Manifold #1 Absolute Pressure : Voltage Below Normal |
1785-4
Intake Manifold Pressure Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 3563-13
Engine Intake Manifold #1 Absolute Pressure : Calibration Required |
1785-13
Intake Manifold Pressure Sensor : Calibration Required |
Troubleshooting, "Sensor Calibration Required - Test" |
| 3563-21
Engine Intake Manifold #1 Absolute Pressure : Data Drifted Low |
1785-21
Intake Manifold Pressure Sensor : Data Drifted Low |
Troubleshooting, "Sensor Supply - Test" |
| 3609-3
DPF #1 Intake Pressure : Voltage Above Normal |
3464-3
DPF #1 Intake Pressure Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 3609-4
DPF #1 Intake Pressure : Voltage Below Normal |
3464-4
DPF #1 Intake Pressure Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 3609-13
DPF #1 Intake Pressure : Calibration Required |
3464-13
DPF #1 Intake Pressure Sensor : Calibration Required |
Troubleshooting, "Sensor Calibration Required - Test" |
| 3609-21
DPF #1 Intake Pressure : Data Drifted Low |
3464-21
DPF #1 Intake Pressure Sensor : Data Drifted Low |
Troubleshooting, "Sensor Supply - Test" |
| 3659-5
Engine Injector Cylinder #1 Actuator #2 : Current Below Normal |
2602-5
Cylinder #1 Injector Actuator #2 : Current Below Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 3659-6
Engine Injector Cylinder #1 Actuator #2 : Current Above Normal |
2602-6
Cylinder #1 Injector Actuator #2 : Current Above Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 3660-5
Engine Injector Cylinder #2 Actuator #2 : Current Below Normal |
2604-5
Cylinder #2 Injector Actuator #2 : Current Below Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 3660-6
Engine Injector Cylinder #2 Actuator #2 : Current Above Normal |
2604-6
Cylinder #2 Injector Actuator #2 : Current Above Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 3661-5
Engine Injector Cylinder #3 Actuator #2 : Current Below Normal |
2606-5
Cylinder #3 Injector Actuator #2 : Current Below Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 3661-6
Engine Injector Cylinder #3 Actuator #2 : Current Above Normal |
2606-6
Cylinder #3 Injector Actuator #2 : Current Above Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 3662-5
Engine Injector Cylinder #4 Actuator #2 : Current Below Normal |
2608-5
Cylinder #4 Injector Actuator #2 : Current Below Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 3662-6
Engine Injector Cylinder #4 Actuator #2 : Current Above Normal |
2608-6
Cylinder #4 Injector Actuator #2 : Current Above Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 3663-5
Engine Injector Cylinder #5 Actuator #2 : Current Below Normal |
2610-5
Cylinder #5 Injector Actuator #2 : Current Below Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 3663-6
Engine Injector Cylinder #5 Actuator #2 : Current Above Normal |
2610-6
Cylinder #5 Injector Actuator #2 : Current Above Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 3664-5
Engine Injector Cylinder #6 Actuator #2 : Current Below Normal |
2612-5
Cylinder #6 Injector Actuator #2 : Current Below Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 3664-6
Engine Injector Cylinder #6 Actuator #2 : Current Above Normal |
2612-6
Cylinder #6 Injector Actuator #2 : Current Above Normal |
Troubleshooting, "Injector Solenoid - Test" |
| 3695-2
Particulate Trap Regeneration Inhibit Switch : Erratic, Intermittent, or Incorrect |
3184-2
DPF Regeneration Inhibit Switch : Erratic, Intermittent, or Incorrect |
The Forced regeneration switch is installed and the disable regeneration switch is held for longer than 1 minute or the Forced regeneration switch is NOT installed and the disable regeneration input through the Datalink is received for longer than 1 minute. |
| 3696-2
Particulate Trap Regeneration Force Switch : Erratic, Intermittent, or Incorrect |
3183-2
DPF Regeneration Force Switch : Erratic, Intermittent, or Incorrect |
The Forced regeneration switch signal is not recognized by the ECM. The switch may not be configured properly for the application or there is a problem with the module it is connected to. |
| 3697-5
Particulate Trap Lamp Command : Current Below Normal |
1090-5
N/A |
Troubleshooting, "Indicator Lamp - Test" |
| 3697-6
Particulate Trap Lamp Command : Current Above Normal |
1090-6
N/A |
Troubleshooting, "Indicator Lamp - Test" |
| 3698-5
Exhaust System High Temperature Lamp Command : Current Below Normal |
1091-5
N/A |
Troubleshooting, "Indicator Lamp - Test" |
| 3698-6
Exhaust System High Temperature Lamp Command : Current Above Normal |
1091-6
N/A |
Troubleshooting, "Indicator Lamp - Test" |
| 3837-3
Aftertreatment 1 Secondary Air Pressure : Voltage Above Normal |
3493-3
Aftertreatment #1 Secondary Air Pressure Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 3837-4
Aftertreatment 1 Secondary Air Pressure : Voltage Below Normal |
3493-4
Aftertreatment #1 Secondary Air Pressure Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 3837-13
Aftertreatment 1 Secondary Air Pressure : Calibration Required |
3493-13
Aftertreatment #1 Secondary Air Pressure Sensor : Calibration Required |
Troubleshooting, "Sensor Calibration Required - Test" |
| 3837-21
Aftertreatment 1 Secondary Air Pressure : Data Drifted Low |
3493-21
Aftertreatment #1 Secondary Air Pressure Sensor : Data Drifted Low |
Troubleshooting, "Sensor Supply - Test" |
| 4077-3
Aftertreatment #1 Fuel Pressure #2 : Voltage Above Normal |
2497-3
ARD Fuel Pressure #2 Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 4077-4
Aftertreatment #1 Fuel Pressure #2 : Voltage Below Normal |
2497-4
ARD Fuel Pressure #2 Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 4212-5
Fan Drive Bypass Command Status : Current Below Normal |
291-5
Engine Cooling Fan Solenoid : Current Below Normal |
Troubleshooting, "Cooling Fan Control - Test" |
| 4212-6
Fan Drive Bypass Command Status : Current Above Normal |
291-6
Engine Cooling Fan Solenoid : Current Above Normal |
Troubleshooting, "Cooling Fan Control - Test" |
| 4212-13
Fan Drive Bypass Command Status : Out of Calibration |
1551-13
Engine Demand Fan System : Out of Calibration |
Troubleshooting, "Cooling Fan - Calibrate" |
| 4214-5
Engine Fan Reverse Actuator : Current Below Normal |
485-5
Engine Fan Reversing Solenoid : Current Below Normal |
Troubleshooting, "Cooling Fan Reversing - Test" |
| 4214-6
Engine Fan Reverse Actuator : Current Above Normal |
485-6
Engine Fan Reversing Solenoid : Current Above Normal |
Troubleshooting, "Cooling Fan Reversing - Test" |
| 4215-3
Ground-Level Shutdown Activated : Voltage Above Normal |
267-3
Remote Shutdown Input : Voltage Above Normal |
Troubleshooting, "Shutdown (Ground Level) - Test" |
| 4215-4
Ground-Level Shutdown Activated : Voltage Below Normal |
267-4
Remote Shutdown Input : Voltage Below Normal |
Troubleshooting, "Shutdown (Ground Level) - Test" |
| 4265-5
Aftertreatment #1 Transformer Secondary Output : Current Below Normal |
3180-5
Aftertreatment #1 Ignition Transformer Secondary : Current Below Normal |
Troubleshooting, "ARD Ignition - Test" |
| 4301-3
Aftertreatment #1 Fuel Injector #1 Heater Control : Voltage Above Normal |
3182-3
Aftertreatment #1 Fuel Injector #1 Heater : Voltage Above Normal |
Troubleshooting, "ARD Nozzle Heater - Test" |
| 4301-4
Aftertreatment #1 Fuel Injector #1 Heater Control : Voltage Below Normal |
3182-4
Aftertreatment #1 Fuel Injector #1 Heater : Voltage Below Normal |
Troubleshooting, "ARD Nozzle Heater - Test" |
| 4301-5
Aftertreatment #1 Fuel Injector #1 Heater Control : Current Below Normal |
3182-5
Aftertreatment #1 Fuel Injector #1 Heater : Current Below Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 4301-6
Aftertreatment #1 Fuel Injector #1 Heater Control : Current Above Normal |
3182-6
Aftertreatment #1 Fuel Injector #1 Heater : Current Above Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 4334-3
Aftertreatment 1 Diesel Exhaust Fluid Doser Absolute Pressure : Voltage Above Normal |
3090-3
Aftertreatment #1 SCR Dosing Reagent Pressure Sensor : Voltage Above Normal |
Troubleshooting, "DEF Pump Pressure Sensor - Test" |
| 4334-4
Aftertreatment 1 Diesel Exhaust Fluid Doser Absolute Pressure : Voltage Below Normal |
3090-4
Aftertreatment #1 SCR Dosing Reagent Pressure Sensor : Voltage Below Normal |
Troubleshooting, "DEF Pump Pressure Sensor - Test" |
| 4334-7
Aftertreatment 1 Diesel Exhaust Fluid Doser Absolute Pressure : Not Responding Properly |
3090-7
Aftertreatment #1 SCR Dosing Reagent Pressure Sensor : Not Responding Properly |
Troubleshooting, "DEF Pressure is Low" |
| 4337-8
Aftertreatment 1 Diesel Exhaust Fluid Dosing Temperature : Abnormal Frequency, Pulse Width, or Period |
3096-8
Aftertreatment #1 SCR Dosing Reagent Temperature #1 Sensor : Abnormal Frequency, Pulse Width, or Period |
Troubleshooting, "DEF Pump - Replace" |
| 4354-5
Aftertreatment 1 Diesel Exhaust Fluid Line Heater 1 : Current Below Normal |
3110-5
Aftertreatment #1 SCR Catalyst Reagent Line Heater #1 : Current Below Normal |
Troubleshooting, "DEF Line Heater - Test" |
| 4354-6
Aftertreatment 1 Diesel Exhaust Fluid Line Heater 1 : Current Above Normal |
3110-6
Aftertreatment #1 SCR Catalyst Reagent Line Heater #1 : Current Above Normal |
Troubleshooting, "DEF Line Heater - Test" |
| 4355-5
Aftertreatment 1 Diesel Exhaust Fluid Line Heater 2 : Current Below Normal |
3111-5
Aftertreatment #1 SCR Catalyst Reagent Line Heater #2 : Current Below Normal |
Troubleshooting, "DEF Line Heater - Test" |
| 4355-6
Aftertreatment 1 Diesel Exhaust Fluid Line Heater 2 : Current Above Normal |
3111-6
Aftertreatment #1 SCR Catalyst Reagent Line Heater #2 : Current Above Normal |
Troubleshooting, "DEF Line Heater - Test" |
| 4356-5
Aftertreatment 1 Diesel Exhaust Fluid Line Heater 3 : Current Below Normal |
3112-5
Aftertreatment #1 SCR Catalyst Reagent Line Heater #3 : Current Below Normal |
Troubleshooting, "DEF Line Heater - Test" |
| 4356-6
Aftertreatment 1 Diesel Exhaust Fluid Line Heater 3: Current Above Normal |
3112-6
Aftertreatment #1 SCR Catalyst Reagent Line Heater #3 : Current Above Normal |
Troubleshooting, "DEF Line Heater - Test" |
| 4360-3
Aftertreatment #1 SCR Catalyst Intake Gas Temperature : Voltage Above Normal |
3105-3
Aftertreatment #1 SCR Catalyst Intake Gas Temperature Sensor : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 4360-4
Aftertreatment #1 SCR Catalyst Intake Gas Temperature : Voltage Below Normal |
3105-4
Aftertreatment #1 SCR Catalyst Intake Gas Temperature Sensor : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 4374-5
Aftertreatment #1 Diesel Exhaust Fluid Pump Motor Speed : Current Below Normal |
3118-5
Aftertreatment #1 SCR Catalyst Reagent Pump Motor Speed Sensor : Current Below Normal |
Troubleshooting, "DEF Pump Motor - Test" |
| 4374-6
Aftertreatment #1 Diesel Exhaust Fluid Pump Motor Speed : Current Above Normal |
3118-6
Aftertreatment #1 SCR Catalyst Reagent Pump Motor Speed Sensor : Current Above Normal |
Troubleshooting, "DEF Pump Motor - Test" |
| 4374-8
Aftertreatment #1 Diesel Exhaust Fluid Pump Motor Speed : Abnormal Frequency, Pulse Width, or Period |
3118-8
Aftertreatment #1 SCR Catalyst Reagent Pump Motor Speed Sensor : Abnormal Frequency, Pulse Width, or Period |
Troubleshooting, "DEF Pump - Replace" |
| 4376-5
Aftertreatment 1 Diesel Exhaust Fluid Return Valve : Current Below Normal |
3862-5
Aftertreatment #1 Diesel Exhaust Fluid Return Valve Solenoid : Current Below Normal |
Troubleshooting, "DEF Return Valve - Test" |
| 4376-6
Aftertreatment 1 Diesel Exhaust Fluid Return Valve : Current Above Normal |
3862-6
Aftertreatment #1 Diesel Exhaust Fluid Return Valve Solenoid : Current Above Normal |
Troubleshooting, "DEF Return Valve - Test" |
| 4376-7
Aftertreatment 1 Diesel Exhaust Fluid Return Valve : Not Responding Properly |
3862-7
Aftertreatment #1 Diesel Exhaust Fluid Return Valve Solenoid : Not Responding Properly |
Troubleshooting, "DEF Pump - Replace" |
| 5276-5
Engine Exhaust Manifold Bank #1 Flow Balance Valve Actuator Control : Current Below Normal |
3409-5
Engine Exhaust Manifold Bank #1 Flow Balance Valve Solenoid : Current Below Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 5276-6
Engine Exhaust Manifold Bank #1 Flow Balance Valve Actuator Control : Current Above Normal |
3409-6
Engine Exhaust Manifold Bank #1 Flow Balance Valve Solenoid : Current Above Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 5423-5
Aftertreatment #1 Fuel Pump Relay Control : Current Below Normal |
3427-5
Aftertreatment Fuel Pump Relay : Current Below Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 5423-6
Aftertreatment #1 Fuel Pump Relay Control : Current Above Normal |
3427-6
Aftertreatment Fuel Pump Relay : Current Above Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 5424-5
Aftertreatment #1 Fuel Flow Diverter Valve Control : Current Below Normal |
3413-5
ARD Fuel Flow Diverter Actuator : Current Below Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 5424-6
Aftertreatment #1 Fuel Flow Diverter Valve Control : Current Above Normal |
3413-6
ARD Fuel Flow Diverter Actuator : Current Above Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 5425-5
Aftertreatment #1 Fuel Pressure #2 Actuator Control : Current Below Normal |
3391-5
ARD Fuel Pressure #2 Control Actuator : Current Below Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 5425-6
Aftertreatment #1 Fuel Pressure #2 Actuator Control : Current Above Normal |
3391-6
ARD Fuel Pressure #2 Control Actuator : Current Above Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 5491-5
Aftertreatment #1 DEF Line Heater Relay : Current Below Normal |
3822-5
Aftertreatment #1 Diesel Exhaust Fluid Line Heater Relay : Current Below Normal |
Troubleshooting, "DEF Line Heater - Test" |
| 5491-6
Aftertreatment #1 DEF Line Heater Relay : Current Above Normal |
3822-6
Aftertreatment #1 Diesel Exhaust Fluid Line Heater Relay : Current Above Normal |
Troubleshooting, "DEF Line Heater - Test" |
| 5576-2
Aftertreatment #1 Identification : Erratic, Intermittent, or Incorrect |
3468-2
Aftertreatment #1 Identification Number Module : Erratic, Intermittent, or Incorrect |
Troubleshooting, "Aftertreatment Identification Module - Test" |
| 5576-8
Aftertreatment #1 Identification : Abnormal Frequency, Pulse Width, or Period |
3468-8
Aftertreatment #1 Identification Number Module : Abnormal Frequency, Pulse Width, or Period |
Troubleshooting, "Aftertreatment Identification Module - Test" |
| 5576-14
Aftertreatment #1 Identification : Special Instruction |
3468-14
Aftertreatment #1 Identification Number Module : Special Instruction |
Troubleshooting, "Data Link Configuration Status - Test" |
| 5577-2
Aftertreatment #2 Identification : Erratic, Intermittent, or Incorrect |
3469-2
Aftertreatment #2 Identification Number Module:Erratic, Intermittent, or Incorrect |
Troubleshooting, "Aftertreatment Identification Module - Test" |
| 5577-8
Aftertreatment #2 Identification : Abnormal Frequency, Pulse Width, or Period |
3469-8
Aftertreatment #2 Identification Number Module:Abnormal Frequency, Pulse Width, or Period |
Troubleshooting, "Aftertreatment Identification Module - Test" |
| 5577-14
Aftertreatment #2 Identification : Special Instruction |
3469-14
Aftertreatment #2 Identification Number Module:Special Instruction |
Troubleshooting, "Data Link Configuration Status - Test" |
| 5578-3
Engine Fuel Delivery Absolute Pressure : Voltage Above Normal |
289-3
Fuel Pressure Sensor - Before Fuel Filter : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 5578-4
Engine Fuel Delivery Absolute Pressure : Voltage Below Normal |
289-4
Fuel Pressure Sensor - Before Fuel Filter : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 5578-21
Engine Fuel Delivery Absolute Pressure : Data Drifted Low |
289-21
Fuel Pressure Sensor - Before Fuel Filter : Data Drifted Low |
Troubleshooting, "Sensor Supply - Test" |
| 5580-3
Engine Filtered Fuel Delivery Absolute Pressure : Voltage Above Normal |
460-3
Fuel Pressure Sensor - After Fuel Filter : Voltage Above Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 5580-4
Engine Filtered Fuel Delivery Absolute Pressure : Voltage Below Normal |
460-4
Fuel Pressure Sensor - After Fuel Filter : Voltage Below Normal |
Troubleshooting, "Sensor Signal (Analog, Active) - Test" |
| 5580-21
Engine Filtered Fuel Delivery Absolute Pressure : Data Drifted Low |
460-21
Fuel Pressure Sensor - After Fuel Filter : Data Drifted Low |
Troubleshooting, "Sensor Supply - Test" |
| 5758-11
Aftertreatment #1 Intake Gas Sensor Power Supply : Other Failure Mode |
3621-11
Engine Exhaust NOx Level Sensor Power Supply : Other Failure Mode |
Troubleshooting, "Electrical Power Supply - Test" |
| 5759-11
Aftertreatment #1 Outlet Gas Sensor Power Supply : Other Failure Mode |
3619-11
Aftertreatment #1 Outlet #1 NOx Level Sensor Power Supply : Other Failure Mode |
Troubleshooting, "Electrical Power Supply - Test" |
| 5965-5
Aftertreatment 1 Diesel Exhaust Fluid Control Module Relay Control : Current Below Normal |
3838-5
Aftertreatment #1 Diesel Exhaust Fluid Dosing Control Module Relay : Current Below Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 5965-6
Aftertreatment 1 Diesel Exhaust Fluid Control Module Relay Control : Current Above Normal |
3838-6
Aftertreatment #1 Diesel Exhaust Fluid Dosing Control Module Relay : Current Above Normal |
Troubleshooting, "Solenoid Valve - Test" |
| 5966-5
Aftertreatment 1 Diesel Exhaust Fluid Control Module Power Supply : Current Below Normal |
3965-5
Aftertreatment #1 Diesel Exhaust Fluid Control Module Power Supply #1 : Current Below Normal |
Troubleshooting, "DEF Control Module Power - Test" |
| 5966-6
Aftertreatment 1 Diesel Exhaust Fluid Control Module Power Supply : Current Above Normal |
3965-6
Aftertreatment #1 Diesel Exhaust Fluid Control Module Power Supply #1 : Current Above Normal |
Troubleshooting, "DEF Control Module Power - Test" |
| 6309-6
Aftertreatment #1 Diesel Exhaust Fluid Control Module Power Supply #2 : Current Above Normal |
3966-6
Aftertreatment #1 Diesel Exhaust Fluid Control Module Power Supply #2 : Current Above Normal |
Troubleshooting, "DEF Control Module Power - Test" |
Caterpillar Information System:
2012/05/14 New Flash Files Are Available for Certain Engines {1901, 1920}
C3.3B and C3.8 Engines for Caterpillar Built Machines Oil Pressure Is Low
C32 Marine Engines Coolant Level Sensor - Remove and Install
2012/05/07 A Procedure to Check Ash Build-up Within the Diesel Particulate Filter (DPF) Is Now Available {108F}
C175-16 Generator Set Refill Capacities
C7.1-XQ230 Rental Generator Set Setup
Inspection and Salvage of Front Wheel Spindles for Off-Highway Trucks {4201, 4205} Inspection and Salvage of Front Wheel Spindles for Off-Highway Trucks {4201, 4205}
C15 and C18 Tier 4 Final Engines DEF Dosing Control System
2012/05/07 An Improved Guide Spring and Valve Lifter Assembly Are Available in Certain C9 ACERT Engines {1209}
C3.3B and C3.8 Engines for Caterpillar Built Machines Fuel Rail Pressure Is Low
C3.3B and C3.8 Engines for Caterpillar Built Machines Engine Vibration Is Excessive
C3.3B and C3.8 Engines for Caterpillar Built Machines Engine Top Speed Is Not Obtained
C9.3 Tier 4 Final Engines Event Codes
2012/06/25 Obsolete Merlin Gerin CK and CM Frame Circuit Breaker Replacements Are Now Available {1420, 4461}
G3516C and G3516E Gas Engines Exhaust Manifold
C9.3 Tier 4 Final Engines Engine Cranks but Does Not Start
325 VM and VH Variable Gauge Undercarriage Final Drive - Disassemble
C32 Marine Engines Engine Oil Pressure Sensor - Remove and Install
2012/08/03 New Thermostats Are Now Used for Jacket Water Heater on Certain Cat Gensets and Cat Engines {1383}
C175-16 Engine for 795F Series AC Off-Highway Trucks Housing (Front)
2012/07/23 New Software Is Used for Certain G3516C Engines {1901, 1920}
C9.3 Tier 4 Final Engines Fuel Consumption Is Excessive
C9.3 Tier 4 Final Engines Fuel Pressure Is High
C13, C15, and C18 Tier 4 Final Engines Fuel Pressure Is Low