Crankcase Pressure Is High
按照此步骤对曲轴箱压力高进行故障诊断与排除。 在以下任一事件码为现行状态时使用本步骤。 有关事件代码和这些代码的默认触发点的信息,参考故障排除, "事件代码"。 必须进入 Caterpillar 电子技师(ET)上的监控系统才能查看这些代码的当前触发点。
Show/hide table
事件代码     | ||
---|---|---|
J1939 代码和说明     | 激活代码的条件     | 系统响应     |
101-15 发动机曲轴箱压力:高 - 最低严重程度 (1)     | 曲轴箱压力高于触发点,延迟时间已经终止。     | 记录该代码。 ECM 可能会使发动机减额或停机。     |
101-16 发动机曲轴箱压力:高 - 中等严重程度(2)     | ||
101-0 发动机曲轴箱压力:高 - 最高严重程度(3)     |
可能原因
- 发动机部件磨损
- 闭式曲轴箱通风(CCV)滤清器堵塞
建议的措施
发动机部件
活塞或活塞环损坏可造成曲轴箱压力过高。 这种状况会导致发动机运转不平稳。 曲轴箱中将会比正常情况有更多的烟雾(窜气)。 压力升高可能会导致通常没有泄漏的密封垫和密封件出现机油泄漏。 窜气也可能因磨损的阀导管或损坏的涡轮增压器密封件而导致的。
CCV 滤清器堵塞
CCV 滤清器堵塞将导致曲轴箱压力过高。 如有配备,曲轴箱压力升高将导致滤清器维修指示灯出现。 曲轴密封泄漏可能发生。 活塞环的密封可能丢失。 曲轴箱窜气增加使曲轴箱压力进一步升高。
根据操作和保养手册, "发动机曲轴箱呼吸器 - 清理"清理曲轴箱呼吸器。 如有必要,更换滤清器,通过松开透明塑料盖上的螺钉并向下推指示灯按钮来复位指示灯。 重新安装盖。
Caterpillar Information System:
C7.1 Engines for Caterpillar Built Machines Camshaft Bearings
CG137-08 and CG137-12 Generator Sets Piston and Rings
SPF343 and SPF343C Trailer Mounted Pumpers Overhaul (Top End)
3500C Marine Engines Engine Oil and Filter - Change
C18 Generator Set Refill Capacities
3516C Generator Set Engines Inlet Air Is Restricted
3512C and 3516C Marine Auxiliary and Generator Set Engines Cooling System Supplemental Coolant Additive (SCA) - Test/Add - Systems Which are Filled with Conventional Coolant or Water/Supplemental Coolant Additive (SCA)
SPF343 and SPF343C Trailer Mounted Pumpers Before Starting Engine
3516C Generator Set Engines Fuel Filter Is Restricted
2011/09/27 New Jacket Water Heater for Certain C1.5 and C2.2 Generator Sets {1383}
C15 and C18 Petroleum Generator Sets Alarms and Shutoffs
C18 Generator Set Product Description
3508B, 3508C, 3512B, 3512C, 3516B and and 3516C Marine Engines Engine Oil Level - Check
370-8568 Bulk Fuel Filtration Group 50 GPM Flow Rate{0599, 0680, 0706, 0782, 1250, 1280} 370-8568 Bulk Fuel Filtration Group 50 GPM Flow Rate{0599, 0680, 0706, 0782, 1250, 1280}
3516C Generator Sets Coolant Level - Check
Protecting the C175 Electronic Thermostat from Moisture Entry{1355, 135V, 1380, 1393} Protecting the C175 Electronic Thermostat from Moisture Entry{1355, 135V, 1380, 1393}
CG137-08 and CG137-12 Generator Sets Flywheel Housing Cover
TA19 M4WD Agricultural Transmission Modulating Valve (Transmission Clutch)
CG137-08 and CG137-12 Generator Sets Engine Oil Filter Base
Fundamentals of HVOF Spray for Reconditioning Components {0599, 0679, 1000, 7000} Fundamentals of HVOF Spray for Reconditioning Components {0599, 0679, 1000, 7000}
CG137-08 and CG137-12 Generator Sets Cylinder Block
CG137-08 and CG137-12 Generator Sets Cover Group (Front Housing)
CG137-08 and CG137-12 Generator Sets Crankshaft Pulley
CG137-08 and CG137-12 Generator Sets Engine Oil Lines