General Information
Show/hide table
机器突然移动或释放气压或油压,可能对机器上或机器附近的人员造成伤亡。 为避免可能造成的伤亡,在测试和调整液压系统之前,遵照以下程序。 |
注: 机器上仅允许停留一位操作员。 让其他所有人员远离车辆或离开操作人员的视野。
- 把机器开到平整水平的地方。 把机器开到远离其他机器的地方。 把机器开到远离其他人员的地方。
- 把变速箱操纵杆移到停车位置。 关闭发动机。
- 启动停车制动器。
- 车轮前后都塞上车轮挡块。 请参阅拆解和组装, "车轮楔子(前和后)- 拆卸和安装"。
- 如有必要抬起卡车的卸载车斗,将固定电缆与卡车后部连接。 请参阅拆解和组装, "卡车车箱固定缆绳 - 拆卸和安装"。
Show/hide table
图 1 | g01561449 |
与卸载车斗连接的固定电缆。 |
- 确保变速箱操纵杆处于停车位置。
- 在任何接头、软管或者部件上工作之前,确保释放所有机油压力。
目视检查是故障诊断与排除的第一步。 目视检查会确定可以快速修正的故障。
由于可能难以进行故障诊断与排除,所以在维修手册上列出了可能故障的列表。 为了维修某个故障,请参阅测试和调整, "故障诊断与排除部分"所列出的故障和可能原因。
问题和可能的原因的列表仅给出存在可能问题的指示,和可能需要修理的指示。 有时候,可能需要列表中建议以外的更多修理或其他修理。 请记住:一个故障通常不会仅仅由单个零件引发。 故障通常由某个零件与其它零件之间的关系引起。 此列表无法提供所有可能的问题和可能的原因。 维修人员必须要找到问题所在和问题的源头。 然后维修人员必须进行必要的修理。
Caterpillar Information System:
C4.4 Industrial Engine Engine Starting
793F and 793F CMD Off-Highway Truck Hydraulic System Hoist Control
793F and 797F Off-Highway Trucks Braking System Glossary of Electrical Terms
793F and 793F CMD Off-Highway Truck Braking System Pressure Sensor (Brake Pump)
793F and 797F Off-Highway Trucks Braking System Automatic Retarder - Calibrate
G3304B and G3306B Engines Aftercooler
CX35-P800 Petroleum Transmission and Petroleum Power Train Packages Pump Drive - Disassemble - Integral
CX35-P800 Petroleum Transmission and Petroleum Power Train Packages Pump Drive - Assemble - Integral
CX35-P800-C18I and CX35-P800-C27I Petroleum Power Train Packages and CX35-P800 Petroleum Transmission Event Code List
793F Off-Highway Truck Engine Supplement Air Starting Motor - Remove and Install
C12 Marine Engines Maintenance Recommendations
C9.3 Engines for Caterpillar Built Machines Diesel Particulate Filter - Remove and Install
Camshaft Lobe Hits Fuel Transfer Pump.{1210, 1256} Camshaft Lobe Hits Fuel Transfer Pump.{1210, 1256}
793F and 793F CMD Off-Highway Truck Braking System Brake System
C175 Generator Sets Starting Motor - Inspect - If equipped
C9 Marine Engines Maintenance Recommendations
Procedure for Installing the Space Heater and Setting the Thermostat on High Voltage Generators{1404, 1408, 4459, 7274} Procedure for Installing the Space Heater and Setting the Thermostat on High Voltage Generators{1404, 1408, 4459, 7274}
797F and 797F XQ Off-Highway Truck Power Train Torque Converter
797F and 797F XQ Off-Highway Truck Power Train Oil Filter (Differential)
C3.4B Engines for Caterpillar Built Machines Alternator - Test
C7.1 Industrial Engine Exhaust Sensor and Lines (NRS)
Piston Seizures on C18 Engines{1225, 1331} Piston Seizures on C18 Engines{1225, 1331}
C11, C13, and C15 On-highway Engines Configuration Parameters
C11, C13, and C15 On-highway Engines Monitoring System