Air Lubricator - Remove and Install
拆卸步骤
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损和缩短部件寿命。 |
Show/hide table
断开储气罐上的供气。 从空气起动系统中排放压缩空气。 压缩空气的突然释放可能会导致人身伤害。 |
Show/hide table
图 1 | g01283637 |
- "断开"储气罐上的供气。 确保气压从空气起动系统中排出。
- 拆下卡箍 (4) 。
- 断开软管组件 (3) 。
- 卸下将空气管组件和垫片固定在空气起动马达上的螺栓 (1) 。 检查密封垫有无损坏。 必要时更换密封垫。
- 卸下空气系统润滑器 (2) 。 将空气系统润滑器 (2) 放置在适当的工作台上。
- 将作为一个整体的接头从空气系统润滑器的两侧卸下。
安装步骤
Show/hide table
所需工具     | |||
工具     | 零件号     | 零件说明     | 数量     |
A     | 6V-6640     | 密封胶     | -     |
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损和缩短部件寿命。 |
Show/hide table
图 2 | g01283637 |
- 将作为一个整体的接头安装在空气系统润滑器 (2) 的两侧。
注: 安装前,向空气系统润滑器 (2) 中注入柴油。
注: 安装前,将工具 (A) 涂在接头上。
- 安装空气系统润滑器 (2) 。
- 检查密封垫有无损坏。 必要时更换密封垫。 安装将空气管组件和垫片固定在空气起动马达上的螺栓 (1) 。
- 连接软管组件 (3) 。
- 安装卡箍 (4) 。
- "接通"储气罐上的供气。
Caterpillar Information System:
2006/06/26 Calibration of the ECPC Valves on Well Servicing OEM Transmissions {3073, 3139, 3167, 4800, 4808, 7000}
C175-16 and C175-20 Generator Set Engines Fan Drive
2006/11/27 The 285-0910 Multi-Tool Gp Incorporates Four Diagnostic Tools into a Single, Hand Held Unit {0774, 0779, 0781, 0782}
UPS 1000S/ UPS 1200S Uninterruptible Power Supplys DC Disconnect Switch Handle
C280-12 and C280–16 Marine Engines Mounting Isolator - Remove and Install
C6.6 Engines for Caterpillar Built Machines Engine Valve Lash - Inspect/Adjust
C9 On-highway Engine Exhaust Combustion Group - Aftertreatment Regeneration Device
3606 and 3608 Engines Engine Support - Remove and Install
UPS 1000S/ UPS 1200S Uninterruptible Power Supplys APS Controller PWA
3500B Industrial Engine Refill Capacities and Recommendations
390F Excavator Machine Systems Travel Motor - Assemble
C9 Engines for Caterpillar Built Machines Engine Design
UPS 1000S/ UPS 1200S Uninterruptible Power Supplys DC Disconnect Indicator
3612 and 3616 Engines Air Starting Motor Silencer - Remove and Install
UPS 1000S/ UPS 1200S Uninterruptible Power Supplys Power Distribution PWA
3612 and 3616 Engines Air Starting Motor - Remove
UPS 1000S/ UPS 1200S Uninterruptible Power Supplys 24V Power Supply
C175-16 and C175-20 Generator Set Engines Fuel Lines
3612 and 3616 Engines Air Starting Motor - Disassemble
G3508, G3512 and G3516 Engines Electric Starting Motor - Remove and Install
Inspection and Repair Procedure to Replace the Studs for the Rocker Arm Shaft{1102} Inspection and Repair Procedure to Replace the Studs for the Rocker Arm Shaft{1102}
UPS 1000S/ UPS 1200S Uninterruptible Power Supplys Dual Network Interface PWA (Flywheel Cabinet)
UPS 1000S/ UPS 1200S Uninterruptible Power Supplys General Purpose Interface PWA (Flywheel Cabinet)
G3500 A3 Engines Gas Engine Ignition