Gear Group (Front)
Show/hide table
Injection timing     | ||
Engine     | Maximum rated engine speed     | Injection timing (BTDC) (1)     |
C1.5 Genset     | 1500     | 14° ± 1°     |
1800 | 14° ± 1°     | |
3000 | 20° ± 1°     | |
C2.2 Genset     | 1500     | 15° ± 1°     |
1800 | 12° ± 1°     | |
3000 | 18° ± 1°     |
Show/hide table
( 1 ) | Before Top Dead Center |
Show/hide table
Illustration 1 | g00836394 |
(1) Timing mark on the camshaft gear
(2) Timing mark on the idler gear
(3) Idler gear
(4) Timing mark on the camshaft gear
Minimum backlash for all gears ... 0.08 mm (0.003 inch)
Maximum backlash for all gears ... 0.25 mm (0.010 inch)
Note: If the backlash is greater than the maximum backlash, replace the camshaft gear, the idler gear and the crankshaft gear.
When the idler gear is installed on the shaft of the oil pump, align a timing mark on idler gear (4) with the timing mark on crankshaft gear (2). Also, align the other timing mark on idler gear (4) with the timing mark on camshaft gear (3).
Caterpillar Information System:
C2.2 Engine and C1.5 Generator Set General Information
C2.2 Engine and C1.5 Generator Set Piston and Rings
C9 Generator Set Self-Diagnostics - If Equipped with EMCP 3
C2.2 Engine and C1.5 Generator Set Connecting Rod
C2.2 Engine and C1.5 Generator Set Engine Design
C2.2 Engine and C1.5 Generator Set Main Bearing Journal
C2.2 Engine and C1.5 Generator Set Connecting Rod Bearing Journal
C2.2 Engine and C1.5 Generator Set Crankshaft
C2.2 Engine and C1.5 Generator Set Cylinder Block
C7 On-highway Engine Cylinder Head
C2.2 Engine and C1.5 Generator Set Water Temperature Regulator
C2.2 Engine and C1.5 Generator Set Engine Oil Relief Valve
3500 Engines Crankcase Pressure (High)
3500 Engines Coolant Temperature Is Too Low
3500 Engines Engine Overspeed
C15 and C18 Petroleum Generator Sets Starting the Engine - EMCP 3
C32 Petroleum Engines Plate Locations and Film Locations
C18 Generator Set Manual Stop Procedure - EMCP 3 (If Equipped)
C32 Petroleum Generator Sets Engine Crankcase Breather - Clean
3500 Engines Fuel Filter Restriction
C2.2 Engine and C1.5 Generator Set Flywheel Housing
C2.2 Engine and C1.5 Generator Set Crankshaft Pulley
C2.2 Engine and C1.5 Generator Set Alternator and Regulator
C2.2 Engine and C1.5 Generator Set Electric Starting Motor