Valve Mechanism Cover Base - Remove and Install
开始:
- 拆卸气门机构盖。 请参阅拆解和组装, "气门机构盖 - 拆卸和安装"。
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损和缩短部件寿命。 |
- 断开线束组件 (3) 和线束组件 (4)。
- 拆卸螺栓 (1)。
- 从缸盖上卸下气门机构盖底座 (2) 和密封。
Show/hide table
图 1 | g01116244 |
Show/hide table
需要的工具 | |||
工具 | 零件号 | 零件名称 | 数量 |
A | 3S-6252 | 密封胶 | 1 |
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损和缩短部件寿命。 |
- 将密封安装在气门机构盖底座上。 在密封接头上使用工具 (A)。
- 将气门机构盖底座 (2) 安置在缸盖上,安装螺栓 (1)。 按数字顺序拧紧螺栓至扭矩为
18 ± 3 N·m (13 ± 2 lb ft) 。 - 将线束组件 (3) 安置在电子单体喷油器上。 拧紧盖螺母至扭矩为
2.5 ± 0.25 N·m (22 ± 2 lb in) 。 - 连接线束组件 (4)。
Show/hide table
图 2 | g01116244 |
Show/hide table
图 3 | g00579307 |
结束:
- 安装气门机构盖。 请参阅拆解和组装, "气门机构盖 - 拆卸和安装"。
Caterpillar Information System:
C15 and C18 Engines for Caterpillar Built Machines Valve Mechanism Cover - Remove and Install
C11 and C13 Engines for Caterpillar Built Machines Sensors and Electrical Connectors
3508B, 3512B and 3516B Generator Set Engines Exhaust Manifold - Remove and Install
C15 and C18 Engines for Caterpillar Built Machines Front Cover - Install
C9 Marine Generator Set Belts - Inspect/Adjust/Replace
C15 and C18 Engines for Caterpillar Built Machines Front Cover - Remove
C15 and C18 Tier 4 Final Engines Turbocharger - Inspect
C15 and C18 Engines for Caterpillar Built Machines Crankshaft Front Seal - Install
C15 and C18 Engines for Caterpillar Built Machines Crankshaft Front Seal - Remove
3126B Petroleum Engine Piston and Rings
2004/11/01 A New Process Helps Prevent Freezing {1063, 1064}
3412E Petroleum Engine Piston and Rings
C-10 Petroleum Engine Valve Mechanism Cover
C3.3 and C4.4 Generator Sets Fuel System Primary Filter/Water Separator - Drain
C15 and C18 Engines for Caterpillar Built Machines Rocker Arm and Shaft - Remove
C15 and C18 Tier 4 Final Engines Cooling System - Check - Overheating
C-10 Petroleum Engine Turbocharger
C15 and C18 Engines for Caterpillar Built Machines Camshaft - Remove
C15 and C18 Engines for Caterpillar Built Machines Camshaft - Install
C-10 Petroleum Engine Exhaust Manifold
C15 and C18 Engines for Caterpillar Built Machines Fuel Filter Pressure Differential Switch
C15 and C18 Engines for Caterpillar Built Machines Pistons and Connecting Rods - Remove
3412E Petroleum Engine General Information
C9 Marine Generator Set Fuel System Secondary Filter - Replace