Fuel Shutoff Solenoid - Test
Show/hide table
Illustration 1 | g00902628 |
This procedure tests the fuel shutoff solenoid for correct operation.
- Remove the fuel shutoff solenoid from the engine. Refer to Disassembly and Assembly, "Fuel Shutoff Solenoid - Remove and Install".
- Connect the fuel shutoff solenoid to a 12 volt power source.
- When the fuel shutoff solenoid is connected, the plunger should extend. The plunger should remain extended until the circuit is de-energized. If the fuel shutoff solenoid fails this test, replace the fuel shutoff solenoid.
- Install the fuel shutoff solenoid on the engine. Refer to Disassembly and Assembly, "Fuel Shutoff Solenoid - Remove and Install".
Caterpillar Information System:
3034 Marine Engine Glow Plugs - Test
G3520B Engines ECM Output Circuit (Fuel Control)
3034 Engine for Caterpillar Built Machines Increased Engine Oil Temperature - Inspect
3056E Industrial Engine Finding Top Center Position for No. 1 Piston
C-10, C-12 and C-15 On-highway Engines 0173-11 Very High Exhaust Gas Temperature Derate
C-10, C-12 and C-15 On-highway Engines 0173-00 High Exhaust Gas Temperature Derate
C-10, C-12 and C-15 On-highway Engines 0102-07 Boost Pressure not responding
C7 and C9 On-Highway Engines 0102-02 Boost Pressure signal erratic
C7 and C9 On-Highway Engines 0102-01 Low Boost Pressure (25)
3056E Industrial Engine Fuel Injection Timing - Check
G3520B Engines Detonation Sensors
3126B Engine for Caterpillar Built Machines Injection Actuation Pressure - Test
G3520B Engines ECM Output Circuit (Starting Motor)
C-10, C-12 and C-15 On-highway Engines Poor Acceleration or Response
C-10, C-12 and C-15 On-highway Engines Low Power/Poor or No Response to Throttle
C-10, C-12 and C-15 On-highway Engines Intermittent Low Power or Power Cutout
3406E, C-10, C-12, C-15, C-16 and C-18 On-highway Engines Intermittent Cruise Control, Idle, or PTO Kickout
3406E, C-10, C-12, C-15, C-16 and C-18 On-highway Engines Cruise Control, Idle, or PTO Can Not Be Set
G3520B Engines ECM Status Indicator Output
3034 Marine Engine Engine Valve Lash - Inspect/Adjust
2005/12/19 A New Check Valve Assembly is Used in the Prechamber Groups {1106}
G3520B Engines Electrical Power Supply
G3600 Engines Flexible Coupling
C0.5, C0.7, C0.7, C1.1/3011C, C1.5/3013C, C1.6 and C2.2/3024C/3024CT Industrial Engines and Engines for Caterpillar Built Machines Cooling System Coolant (DEAC) - Change