Camshaft Bearings - Remove
拆卸步骤
Show/hide table
所需工具     | |||
工具     | 零件号     | 零件说明     | 数量     |
A     | 6V-4077     | 凸轮轴轴承工具     | 1     |
125-2739 (1) | 轴承安装引导器     | 1     | |
125-2740 (1) | 备用板     | 1     | |
125-2741 (1) | 轴承套     | 1     | |
B     | 8S-2241     | 凸轮轴轴承工具总成     | 1     |
C     | 5P-5247     | 液压拉拔器     | 1     |
D     | 8H-0684     | 棘轮扳手     | 1     |
Show/hide table
( 1 ) | 大直径凸轮轴轴承的备用工具 |
开始:
- 拆卸凸轮轴。 请参考拆解和组装, "凸轮轴 - 拆卸"。
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损和缩短部件寿命。 |
- 采用以下步骤安装工具 (A) 。
- 将先导总成安装到凸轮轴轴承 (1) (未显示)。
- 将垫板就位并确保凸轮轴轴承 (1) (未显示)位于两个零件之间。
- 安装将工具 (A) 固定在一起的螺栓。
- 使用延长板获得工具 (A) 的正确长度。
- 在螺栓和飞轮壳体或前壳体上安装拉拔器板。
注: 拆卸飞轮壳体和前壳体时可用工具 (B) 来拆卸凸轮轴轴承。
Show/hide table
图 1 | g01208871 |
- 在工具 (A) 上安装工具 (C) 。 从缸体中拨出凸轮轴轴承 (1) 。
注: 如有必要,用工具 (D) 代替工具 (C) 。
Show/hide table
图 2 | g01208875 |
Caterpillar Information System:
3126B and 3126E On-highway Engines Water Pump - Install
3034 Marine Engine Water Temperature Regulator Housing
3126 Truck Engine Military Water Pump - Remove
G3612 and G3616 Engines Valve Lifter - Assemble
G3612 and G3616 Engines Valve Lifter - Disassemble
G3612 and G3616 Engines Valve Lifter - Install
Generator Set Load Sensor Installation Requirements
G3612 and G3616 Engines Valve Lifter - Remove
3524B Engine for Caterpillar Built Machines Crankshaft - Install
3126B Engines for Caterpillar Built Machines Crankshaft Wear Sleeve (Rear) - Remove - If Equipped
Electronic Modular Control Panel II (EMCP II) For MUI Engines Troubleshooting Diagnostic Codes
3512B Marine Auxiliary Engine Flexible Coupling
3500B Engines Camshaft Bearings - Install
3126B Engines for Caterpillar Built Machines Water Pump - Disassemble
SR4B Generators Winding - Test
SR4B Generators Resistor - Test
C-15, C-16 and C-18 Truck Engines Water Temperature Regulator - Remove and Install
3126B Engines for Caterpillar Built Machines Water Pump - Assemble
3054B Industrial Engine Reference Material
3114, 3116 and 3126 Engines Air Inlet Heater - If Equipped
3114, 3116 and 3126 Engines Little or No Valve Lash
3114, 3116 and 3126 Engines Loss of Coolant
SR4B Generators Leads - Connect
3406E Generator Set Engines Customer Specified Parameters