Transmission System Oil Sample - Obtain
Show/hide table
 |
热油和热的部件可能会导致人身伤害。 不要让热油或热的部件与皮肤接触。 |
Show/hide table
| 注意 |
|---|
在进行检验、保养、测试、调整及维修产品期间，必须小心以确保装好排放出的油液。 在打开任何舱室或解体任何储有液体的部件之前，要准备好合适的容器收集液体。 有关收集和盛接 Cat 产品上油液的适用工具和用品，请参阅专门出版物, NENG2500, "代理商维修工具目录"。 按照当地法规和要求处置所有液体。 |
对变速箱油进行取样的时间应尽可能靠近推荐的取样间隔。 建议的取样间隔为每 500 工作小时。 为了获得最佳的 S·O·S 油样分析效果，必须建立一个一致的数据趋势。 为建立适当的数据历史，必须以均匀的间隔进行一致的机油取样。
S·O·S 采样孔位于变速箱油滤清器底座上。
- 变速箱油滤清器位于操作台下方，靠近右挡泥板。
Show/hide table
 | |
| 图 1 | g02549100 |
后视图 | |
- 拆下取样端口的保护盖。
Show/hide table
 | |
| 图 2 | g01210348 |
- 获取变速箱油样。 有关获取变速箱油样的资料，请参阅专门出版物, SEBU6250, "S·O·S 油样分析"。
- 完成取样后，从瓶中取出带导管的盖和探头。 废弃带导管的盖和探头。 安装 169-8373 油样瓶附带的密封盖 。
- 更换保护帽。
有关变速箱系统机油的更多信息，请参阅专门出版物, SEBU6250, "Caterpillar 机器油液建议"，或咨询您的 Caterpillar 代理商。
Caterpillar Information System:
521B and 522B Track Feller Bunchers Swing Drive Oil Sample - Obtain
521B and 522B Track Feller Bunchers Swing Drive Oil - Change
AP1000F Asphalt Paver Machine Systems Hydraulic Filter (Suction Return) - Remove and Install
541 Series 2 and 552 Series 2 Track Feller Bunchers Refrigerant Dryer - Replace
541 Series 2 and 552 Series 2 Track Feller Bunchers Hydraulic System Oil Sample - Obtain
C9.3 Engines for Caterpillar Built Machines Inlet Manifold - Remove and Install
541 Series 2 and 552 Series 2 Track Feller Bunchers Hydraulic System Oil Level (Hood Tilt) - Check
541 Series 2 and 552 Series 2 Track Feller Bunchers Hydraulic System Oil Level - Check
AP1055E Asphalt Paver Equipped with a Cat C6.6 Engine Safety Messages
541 Series 2 and 552 Series 2 Track Feller Bunchers Hydraulic System Oil Filter (Return) - Replace
541 Series 2 and 552 Series 2 Track Feller Bunchers Hydraulic System Oil Filter (Case Drain) - Replace
541 Series 2 and 552 Series 2 Track Feller Bunchers Hydraulic System Oil Filter (Pilot) - Replace
AP1000E and BG1000E Asphalt Pavers Machine Systems Piston Pump (Auxiliary) - Remove
AP1000E and BG1000E Asphalt Pavers Machine Systems Piston Pump (Auxiliary) - Install
PL83 Pipelayer Reference Material
NEHS1126: 370-8570 Bulk Fuel Filtration Group 200 GPM Flow Rate {0599, 0680, 0706, 0782, 1250, 1280} NEHS1126: 370-8570 Bulk Fuel Filtration Group 200 GPM Flow Rate {0599, 0680, 0706, 0782, 1250, 1280}
C13, C15, and C18 Tier 4 Final Engines Exhaust Gas Valve (NRS)
2011/05/26 New Cylinder Pack Assemblies Are Available in Sets for Certain Machines Equipped with C18 Engines {1201, 1216, 1225, 1239}
777G Off-Highway Truck Lubrication Pump Oil Level - Check
Comfort Series Seat For Caterpillar Machines Optimized Seat with Lumbar, Side Controls, and Slide Swivel
777G Off-Highway Truck Lubrication Pump Oil - Change
3516B Engine for 994F and 994H Wheel Loaders Configuration Parameters
AP1000E and BG1000E Asphalt Pavers Machine Systems Piston Motor (Propel) - Remove
AP1000E and BG1000E Asphalt Pavers Machine Systems Piston Motor (Propel) - Install