Differential and Bevel Gear - Install
Show/hide table
所需工具 | |||
工具 | 零件号 | 零件描述 | 数量 |
B | 128-4773 | 提升支架延长件 | 1 |
128-4775 | 起重支架总成 | 1 | |
D | 6V-7030 | 千分尺深度表总成 | 1 |
E | 155-0695 | 螺纹锁固胶 | - |
Show/hide table
车斗降下后,车斗与机架之间没有空隙。 如果不安装固定缆线,可能会导致在此区域作业的人员受伤或死亡。 |
Show/hide table
滚热的油或液压油的压力会对人员造成伤害。 发动机停机之后,液压油的压力仍会保留在液压系统里。 对液压系统进行维修之前,如果不事先释放压力,可能会造成严重伤害。 卸下液压系统的部件或管路时,确保所有的作业机具都已降到地面上,而且液压油温度已冷。 只能在发动机停机,并且加注口盖冷却到可以用徒手触摸时才能卸下加注口盖。 |
- 安装 O 形密封圈 (15)。
Show/hide table
图 2 g01954840 - 安装吸油壳体 (14)。 将工具 (E) 涂抹到螺栓 (13) 上。 安装螺栓 (13)。
Show/hide table
图 3 g01957876 - 安装 O 形密封圈 (12)。
Show/hide table
图 4 g01954825 Show/hide table图 5 g01954834 - 使用工具 (B) 和适当的起吊设备安装差速器和伞齿轮 (9)。 差速器及伞齿轮 (9) 的重量约为
1275 kg (2810 lb) 。 - 安装隔套 (11) 和螺栓 (10)。 拧紧螺栓 (10) 至扭矩为
460 ± 60 N·m (339± 44 lb ft) 。 - 拆下工具 (B)。
Show/hide table
图 6 g01954822 - 连接线束组件 (8)。
Show/hide table
图 7 g01954820 - 连接软管组件 (7)。
Show/hide table
图 8 g01954813 - 安装线束组件 (6)。
Show/hide table
图 9 g01957874 - 安装 O 形密封圈 (5)。 安装销 (4)。
Show/hide table
图 10 g01957873 - 使用工具 (D) 测量从销 (4) 顶端到后桥壳体的距离。 记录测量值并减去
.050 ± .020 mm (0.0020 ± 0.0008 in) ,得到垫片的厚度。Show/hide table图 11 g01954810 - 安装垫片 (3)。 安装盖 (2) 和螺栓 (1)。 将螺栓 (1) 拧紧至扭矩
100 ± 20 N·m (74 ± 15 lb ft) 。
Show/hide table
图 1 | g01957879 |
结束:
- 安装变速箱和分动器。
- 安装齿轮泵(后桥润滑)。
- 安装半轴。
Caterpillar Information System:
793F Off-Highway Truck Power Train Traction Control System (TCS) Wheel Speed Ring - Remove and Install
CD54 Paving Compactor Switch (Sidecutter) - Test
2009/08/17 New Hose Clamps Update the Water Lines Groups {1380}
422E, 428E, 432E, 434E, 442E and 444E Backhoe Loaders Machine Systems Cab - Remove
422E, 428E, 432E, 434E, 442E and 444E Backhoe Loaders Machine Systems Link Assemblies (Upper) - Remove and Install
2009/08/24 New Fuel Injection Lines {1251, 1252}
797F and 797F XQ Off-Highway Truck Braking System Solenoid Valve (Rear Axle Motor Unloader)
797F and 797F XQ Off-Highway Truck Braking System Solenoid Valve (Brake Cooling)
MINEGEM Machine Control ; Guidance Products Local Area Radio Network Site Server - Test
MINEGEM Machine Control ; Guidance Products Local Area Radio Network Signal Strength at Machine - Test
MINEGEM Machine Control ; Guidance Products Local Area Radio Network Local Area Radio Network Communications - Test
MINEGEM Machine Control ; Guidance Products Local Area Radio Network Communication to a New Machine - Test
CD54 Paving Compactor Solenoid Valve (Chip Spreader) - Test
AP-1055D and BG-2455D Asphalt Pavers Track Roller Frame - Lubricate
793D Off-Highway Truck Engine Supplement Engine and Torque Converter - Remove and Install
C4.4 Industrial Engine Engine Stopping
793F Off-Highway Truck Power Train Torque Converter - Remove and Install
12M Motor Grader Caterpillar Approved Work Tools
793F Off-Highway Truck Power Train Relief Valve (Torque Converter Inlet) - Remove and Install
793F Off-Highway Truck Power Train Relief Valve (Torque Converter Outlet) - Remove and Install
422E, 428E, 432E, 434E, 442E and 444E Backhoe Loaders Machine Electronics and Electrical Systems Location of Electrical Components
2009/09/30 A New Front Suspension Frame Bearing Is Now Used {7050, 7203}
793F Off-Highway Truck Power Train Relief Valve (Torque Converter Inlet, Torque Converter Outlet) - Disassemble
CD54 Paving Compactor Steering Wheel Encoder - Test