Fuel Filter Is Restricted
ECM(Electronic Control Module,电子控制模块)检测到燃油滤清器差压异常。
如果下列事件代码激活,采用此步骤。 有关事件代码和此代码的默认触发点的信息,请参阅故障诊断与排除, "事件代码"。 必须进入 Caterpillar ET(Electronic Technician,电子技师)的监控系统才能查看此代码的当前触发点。
Show/hide table
事件代码     | ||
---|---|---|
代码和描述     | 产生此代码的状况     | 系统响应     |
E390(1) 燃油滤清器阻塞     | 经过过滤的燃油压力与未经过滤的燃油压力之差大于触发点压力。 该事件代码的延迟时间为一小时。     | 将会记录该代码。     |
E390(2) 燃油滤清器阻塞     | 经过过滤的燃油压力与未经过滤的燃油压力之差大于触发点压力。 该事件代码的延迟时间为一小时。     | 发动机 ECM 会使发动机功率减额。 将会记录该代码。     |
可能原因
- 燃油滤清器滤芯
建议的措施
燃油滤清器滤芯
- 更换燃油滤清器滤芯。
- 重新起动发动机。
- E390(1) 事件代码的延迟时间为 1 小时。 如果更换燃油滤清器后不久事件代码变为激活状态,则故障可能是电气故障。 有关对油路进行故障诊断与排除的步骤,请参阅故障诊断与排除, "燃油滤清器压差 - 测试"。
Caterpillar Information System:
C9 Engines for Motor Graders Fuel Filter Differential Pressure - Test
G3520C and G3520E Generator Set Engines Electrical Power Supply - Test
C11 and C13 Engines and 14M and 16M Motor Graders CAN Data Link - Test
G3520C and G3520E Generator Set Engines Detonation - Test
G3520C and G3520E Generator Set Engines Turbocharger Compressor Bypass - Test
C1.1, C1.5 and C2.2 Engines for Caterpillar Built Machines Crankcase Breather - Remove and Install - Turbocharged Engines
C0.5, C0.7, C1.1, C1.5, C1.6 and and C2.2 Industrial Engines Crankcase Breather - Remove and Install - Naturally Aspirated Engines
C0.5, C0.7, C1.1, C1.5, C1.6 and and C2.2 Industrial Engines Coolant Temperature Switch - Remove and Install - C1.1, C1.5, C1.6 and C2.2 Engines
C0.5, C0.7, C1.1, C1.5, C1.6 and and C2.2 Industrial Engines Coolant Temperature Switch - Remove and Install - C0.5 and C0.7 Engines
C1.1, C1.5 and C2.2 Engines for Caterpillar Built Machines Connecting Rod Bearings - Remove - Connecting rods in position
C0.5, C0.7, C1.1, C1.5, C1.6 and and C2.2 Industrial Engines Connecting Rod Bearings - Install - Connecting rods in position
C0.5, C0.7, C1.1, C1.5, C1.6 and and C2.2 Industrial Engines Camshaft - Remove
Determining the Cause of Fuel Dilution of Engine Oil {1101, 1124, 1251, 1280, 1290} Determining the Cause of Fuel Dilution of Engine Oil {1101, 1124, 1251, 1280, 1290}
C13 On-highway Engine Air Lines
C11 and C13 Engines and 14M and 16M Motor Graders Fuel Transfer Pump - Test
G3520C and G3520E Generator Set Engines Fuel Control - Test
C13 On-highway Engine Air Lines
C11 and C13 Petroleum Engines Air Lines
G3520C and G3520E Generator Set Engines Fuel Metering Valve - Test
2006/10/02 Use Only Cleaning Agents that are Water Based with the 212-1503 Parts Washer Kit {0680}
G3520C and G3520E Generator Set Engines Ignition Primary - Test
G3520C and G3520E Generator Set Engines Ignition Secondary - Test
Bench Test Procedure for Hydraulic Piston Pumps {5070} Bench Test Procedure for Hydraulic Piston Pumps {5070}
C15 On-Highway Engine Exhaust Manifold