Alternator and Regulator
Note: Load the battery with a carbon pile 4C-4911 Battery Load Tester in order to get the maximum alternator output.
Show/hide table
Illustration 1 | g01269389 |
(1) Alternator and regulator
- Voltage ... 13.5 V
- Output current at 1500 rpm ... 20 amp or higher
- Output current at 3000 rpm ... 50 amp or higher
- Output current at 5000 rpm ... 60 amp or higher
Adjusting voltage of the regulator at 5000 rpm with a load of 5 amp or lower ... 14.2 V to 14.8 V
Caterpillar Information System:
3046 Engine for Caterpillar Built Machines Belt Tension Chart
2003/08/01 New Hose Improves the Drainage of Oil from the Turbocharger During a Continuous Prelube Cycle {1052}
G3500B Engines Compressor Bypass - Check
Circuit Breaker Harness Assembly {1420} Circuit Breaker Harness Assembly {1420}
3406E, C-10, C-12, C-15, C-16 Truck Engines Refill Capacities and Recommendations
C15 On-highway Engine Inlet and Exhaust Valve Springs - Remove and Install
C15 and C18 Generator Set Engines Cylinder Liner - Remove
C15 and C18 Generator Set Engines Cylinder Liner - Install
3126E and 3126B Commercial and Truck Engines Engine Oil and Filter - Change
2003/12/01 SOLAS Requirements for Fuel Lines {1274}
C11 and C13 Engines Diverter Valve (Coolant) - Remove
C11 and C13 Engines Engine Oil Cooler - Remove
3044C Industrial Engine and Engines for Caterpillar Built Machines Electric Starting Motor
C11 and C13 Engines Air Compressor Drive Gear - Remove and Install
C27 and C32 Generator Set Engines Camshaft Bearings - Remove
C27 and C32 Generator Set Engines Camshaft Bearings - Install
C11 and C13 Engines Diverter Valve (Coolant) - Install
2003/08/01 Diagnosis of Failure of Exhaust Valve {1105}
G3406 Engines Camshaft
C11 and C13 Engines Precooler - Remove
3408E and 3412E Engines for Caterpillar Built Machines Cylinder Block
C11 and C13 Engines Precooler - Install
G3500B Engines Engine Crankcase Breather - Clean
C-15 On-Highway Engine Fuel Recirculation Valve - Remove and Install