Connecting Rod - Inspect
本步骤用来确定连杆的下述特点:
- 连杆扭曲度
- 连杆孔的平行度
Show/hide table
图 1 | g00690891 |
检查连杆平行度。 (1) 测量销 (2) 连杆 (A) 测量自连杆的距离 (B) 测量活塞销轴承孔与连杆轴承孔的中心距。 |
- 使用适当的工具测量连杆 (2) 的距离。
- 适当的距离测量仪
- 测量销 (1)
注: 进行测量之前应先卸下连杆轴承。
- 测量连杆扭曲度和两个孔的平行度。
必须在距离 (A) 处进行测量。 连杆两侧的距离 (A) 数值为
100 mm (3.94 inch) 。测量长度 (B)。
各侧之间长度 (B) 的测量值总差变化不得超过
± 0.08 mm (± 0.0031 inch) 。 - 检查活塞销轴承和活塞销有无磨损和其它损坏。
- 测量活塞销在活塞销轴承中的间隙。 有关间隙尺寸的信息,请参阅技术规格, "连杆"。
Caterpillar Information System:
2002/08/26 VIMS Service Port Information {7601}
797 Off-Highway Truck Hydraulic System Screen (Hoist)
143H and 163H Motor Graders All Wheel Drive Electrical Input Components
2002/08/05 A Special Instruction, REHS1314, "Replacement Instructions for the P2 Pressure Sensor on D250E and D300E Articulated Trucks" Is Available {1435}
793C XQ Off-Highway Truck and 793C Off-Highway Truck Engine Supplement Piston Pump (Fan Drive) - Install
2002/08/05 A Special Instruction, REHS1378, "Replacement Instructions for the P2 Pressure Sensor on D250E Series II and D300E Series II Articulated Trucks" Is Available {1435}
R2900 Load Haul Dump General Torque Information
143H and 163H Motor Graders All Wheel Drive Electrical Schematic
797 and 797B Off-Highway Truck Hoist System Enable - Check
784C and 785C Off-Highway Truck/Tractors Air System and Brakes Bypass Switch (Parking Brake Release Hydraulic Filter)
TH220B, TH330B, TH340B, TH350B, TH355B, TH360B, TH460B, TH560B and TH580B Telehandlers MID 039 - CID 0110 - FMI 04
797 and 797B Off-Highway Truck Power Train Electronic Control System MID 081 - CID 1675 - FMI 05
143H and 163H Motor Graders All Wheel Drive Electrical Output Components
776D, 777D and 777D HAA Off-Highway Truck/Tractors Air System and Brakes Air Control Valve (Service Brake)
PS-360B Paving Compactor Safety Messages
814F Wheel Tractor, 815F Soil Compactor and 816F Landfill Compactor Machine Systems Front Frame from Rear Frame - Separate
TH220B, TH330B, TH340B, TH350B, TH355B, TH360B, TH460B, TH560B and TH580B Telehandlers MID 039 - CID 0177 - FMI 03
TH220B, TH330B, TH340B, TH350B, TH355B, TH360B, TH460B, TH560B and TH580B Telehandlers MID 039 - CID 0177 - FMI 04
120H and 135H Motor Graders Machine Systems Fan and Gear Motor (Hydraulic Fan) - Remove
HH45, HH55, HH65 and HH75 Harvester Heads Tree Harvester Head Color Marking System Pump - Assemble - If Equipped
HH45, HH55, HH65 and HH75 Harvester Heads Tree Harvester Head Color Marking System Pump - Disassemble - If Equipped
HH45, HH55, HH65 and HH75 Harvester Heads Tree Harvester Head Color Marking System Components - Install - If Equipped
HH45, HH55, HH65 and HH75 Harvester Heads Tree Harvester Head Color Marking System Components - Remove - If Equipped
R1600 Load Haul Dump Machine Electrical System Autoshift Control (STIC Steering)