Change to Disassembly and Assembly Manual {1157}
- Machine Engines:
- 3176C (S/N: 3PD)
- 3196 (S/N: 5ED)
- C-12 (S/N: JAC; CPN)
Reference: A torque sequence for the bolts that mount the flywheel housing to the cylinder block has been added to the Installation Procedure for the flywheel housings on these machine engines. This change is shown in the text that follows. This change will be included in the next revision of these manuals.
Installation Procedure
- Apply 1U-6396 O-Ring Assembly Compound to O-ring seal (4). Install O-ring (4) .
Show/hide table
Illustration 1 | g00514040 |
- Apply 1U-8846 Sealant (6) to the rear face of the cylinder block. Refer to Illustration 1.
- Make sure that dowels (3) are installed in the rear of the cylinder block. Position flywheel housing (2) on dowels (3) on the rear of the cylinder block. Install twelve bolts (1) and the washers. Use the torque sequence that is shown in Illustration 3 to tighten bolts (1) .
Show/hide table
Illustration 2 | g00514036 |
Show/hide table
Illustration 3 | g00871860 |
Torque sequence |
End By:
a. - Install the crankshaft rear seal. Refer to Disassembly and Assembly, "Crankshaft Rear Seal - Install" .
b. - Install the flywheel. Refer to Disassembly and Assembly, " Flywheel - Install".
Caterpillar Information System:
814F Wheel Tractor, 815F Soil Compactor and 816F Landfill Compactor Braking System Accumulator Charging Valve (Brake)
C-9 Engine for the 12H Motor Grader Can Not Reach Top Engine RPM
2002/04/01 A 6 Micron Element is Available for the Transmission Charging System {3004, 5068}
RM-350B Road Reclaimer/Soil Stabilizer Engine Start Switch
814F Wheel Tractor, 815F Soil Compactor and 816F Landfill Compactor Braking System Brake Accumulator
3126B Engine for 570B and 580B Wheel Harvesters Electrical Power Supply Circuit - Test
2002/03/11 A New Compressor Drive Belt Is Available {1357}
RM-350B Road Reclaimer/Soil Stabilizer Battery Disconnect Switch
311B, 312B, 315B, 318B, 320B, 322B, 325B, 330B, 345B, 345B Series II, 365B and 385B Excavators Air Conditioning and Heating General Troubleshooting Information
311B, 312B, 315B, 318B, 320B, 322B, 325B, 330B, 345B, 345B Series II, 365B and 385B Excavators Air Conditioning and Heating Visual Inspection
2002/03/11 A New Crankshaft Pulley Is Used On The Engine Crankshaft {1205}
2002/05/20 Installing the Feeder House Drum Rings on Lexion Combines May Reduce the Amount of Bending of the Slats {6908}
24H Motor Grader Tandem Breather - Clean/Replace
554 Forwarder and 574 Forwarder Walk-Around Inspection
C-9 Engine for the 12H Motor Grader Engine Cranks but Will Not Start
TH220B, TH330B, TH340B, TH350B, TH355B, TH360B, TH460B, TH560B and TH580B Telehandlers Braking System Service Brake Discs - Check
TH220B, TH330B, TH340B, TH350B, TH355B, TH360B, TH460B, TH560B and TH580B Telehandlers Braking System Parking Brake Control - Check and Adjust
RM-350B Road Reclaimer/Soil Stabilizer Rotor Bearing Reservoir Breather - Replace
RM-350B Road Reclaimer/Soil Stabilizer Parking Brake Control
RM-350B Road Reclaimer/Soil Stabilizer Rotor Chain Drive Case Oil - Change
Contour Series Seat Air Suspension with Air Valve Knob Height Adjustment - Disassemble
RM-350B Road Reclaimer/Soil Stabilizer Rotor Chain Drive Case Oil Level - Check
RM-350B Road Reclaimer/Soil Stabilizer Rotor Bearing Reservoir Oil Sample - Obtain
554 Forwarder and 574 Forwarder Engine Starting