C-15 and C-16 Industrial Engines Caterpillar


Air Starting System

Usage:

MTC855 818
起动发动机,可使用选装的空气起动马达将发动机飞轮旋转到起动所需的适当转速。


图 1g00736474

典型的空气起动系统

(1) 空气起动控制阀

(2) 空气起动马达

(3) 中继阀

(4) 润滑器

空气起动马达 (2) 可安装在发动机的任何一侧。 通常空气盛装在储气罐中。 当被被注满时,储气罐应使其内所容空气的压力保持在1720 kPa (250 psi)。

对于起动时没带重载的发动机,调节阀的设定值大约为690 kPa (100 psi)。 此设定值是以下情况的良好折衷:

  • 起动发动机所需的发动机盘车转速

  • 储气罐内空气的容积

如果起动时发动机带有无法脱开的重载,则需要更高的气压调节阀设定值,以便获得足够高的转速使发动机容易起动。

空气消耗量与转速有直接关系。 同时,气压与使发动机飞轮旋转所需的力有关。 必要时可将气压调节阀调整到1030 kPa (150 psi)以便使重载发动机能够产生足够高的盘车转速。 设定值经正确调定时,空气起动马达能够将带有额外载荷的发动机转动得和不带额外载荷的发动机一样快。

其它具有正确的压力和容量的气源都可以使用。 为使空气起动马达寿命长,供气必须无灰尘和水。 空气起动马达使用的最大压力为1030 kPa (150 psi)。




图 2g00736587

空气起动马达

(5) 进气口

(6) 叶片

(7) 转子

(8) 小齿轮

(9) 齿轮

(10) 活塞

(11) 活塞弹簧

来自气源的供气流动中继阀 (3) 。 空气起动控制阀 (1) 与中继阀之前的管路连通。 气流止于中继阀之前,直到空气起动控制阀 (1) 被启动。 此时,来自控制阀的空气流向空气起动马达小齿轮 (8) 的后面的活塞 (10) 。 作用在活塞 (10) 上的气压压缩活塞弹簧 (11) 。 同时,作用在活塞 (10) 上的气压使小齿轮 (8) 与飞轮齿圈啮合。 当小齿轮处于啮合状态时,空气可经另外的管路流出并到达中继阀。 此空气启动中继阀,开启了通向空气起动马达的供气管路。

该气流流经润滑器 (4) 以便获得润滑空气起动马达的润滑油。

带有润滑油的空气经进气口 (5) 流入空气起动马达。 气压推动转子 (7) 上的叶片 (6) 。 这就会使与齿轮 (9) 和马达小齿轮 (8) 的驱动轴相连的转子转动,小齿轮进而转动发动机飞轮。

发动机开始运转时,飞轮将会比小齿轮 (8) 转得快。 在此情况下,小齿轮 (8) 将回缩。 这就防止对马达、小齿轮 (8) 或飞轮齿圈造成损坏。

当空气起动控制阀 (1) 被释放时,流向小齿轮 (8) 后面的活塞 (10) 的气流和气压作用被中止。 活塞弹簧 (11) 使小齿轮 (8) 回缩。 中继阀 (3) 中止流向空气起动马达的气流。

Caterpillar Information System:

2000/09/04 Correction to the Callouts for the Extender Cylinder {5640, 6640, 6641}
950G and 962G Wheel Loaders and IT62G Integrated Toolcarrier Power Train Oscillating Axle (Rear) - Install
950G and 962G Wheel Loaders and IT62G Integrated Toolcarrier Power Train Oscillating Axle (Rear) - Remove
631E Series II, 633E Series II and 637E Series II Wheel Tractor-Scrapers Air System and Brakes General Troubleshooting Information
IT28G and IT38G Integrated Toolcarriers and 924G, 924GZ, 928G and 938G Wheel Loaders Power Train Electronic Control System Transmission Control (Shift Lever)
120H, 12H, 135H, 140H, 143H, 14H, 160H, 163H and 16H Motor Graders Caterpillar Monitoring System Charging System
PF-300B and PS-300B Pneumatic Compactors Propel System Torque Converter
IT28G and IT38G Integrated Toolcarriers and 924G, 924GZ, 928G and 938G Wheel Loaders Power Train Electronic Control System Limit Switch (Parking Brake)
Caterpillar Monitoring System Alert Indicator Never Flashes
2001/04/23 Mount Accessories in the Cab with Tapped Holes {7177, 7301, 7325}
Service Life can be Increased with the Installation of LED Lights{1429} Service Life can be Increased with the Installation of LED Lights{1429}
3456 Engine, 836G Landfill Compactor, 834G Wheel Dozer and 988G Wheel Loader Compression Brake Solenoid Circuit - Test
834G Wheel Tractor and 836G Landfill Compactor Machine Systems Gear Pump (Implement, Pilot and Braking) - Assemble
2000/09/25 A New Modification Is Used After the Installation of the Bushing in the Harvester Head and Grapple Damper {5569}
CP-323C and CS-323C Paving Compactors Radiator Core - Clean
2000/08/28 Special Instruction, REHS0894, "Speed Sensor Installation" {4351, 4803, 5058}
2000/08/28 Special Instruction, REHS0895, "Speed Sensor Installation" {4351, 4803, 5058}
TH62, TH63, TH82, TH83 and TH103 Telehandlers Power Train Service and Parking Brake - Install
HH45 Harvester Head, HH55 Harvester Head, HH65 Harvester Head and HH75 Harvester Head Cold Weather Operation
2000/10/09 New Hinges Are Used on the Compartment Doors of Wheel Harvesters {7273}
C-10 and C-12 Industrial Engines Rear Power Take-Off (RPTO)
HH45 Harvester Head, HH55 Harvester Head, HH65 Harvester Head and HH75 Harvester Head Harvester Head
950G Wheel Loader, 962G Wheel Loader and IT62G Integrated Toolcarrier Engine Supplement Governor and Fuel Transfer Pump - Install
Caterpillar Monitoring System Temperature Sender
Back to top
The names Caterpillar, John Deere, JD, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
CH-Part.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only.