Pump Drive - Install
Show/hide table
所需工具 | |||
---|---|---|---|
工具 | 零件号 | 零件说明 | 数量 |
A | 138-7575 | 连杆支架 | 1 |
注: 检查所有 O 形密封圈和部件有无磨损或损坏。 如有必要,请更换部件。 利用正要密封的润滑剂稍微润滑所有 O 形密封圈。 利用不起毛的抹布擦拭所有部件。
- 将工具 (A) 固定到泵驱动装置 (4) 上。 将适当的吊索固定到工具 (A) 上。 将吊索固定到适当的举倾机构上。 将泵驱动装置 (4) 提升到机器上的适当位置,如图所示。 泵驱动装置的重量为
68 kg (150 lb) 。 - 安装将泵驱动装置 (4) 固定到机架组件上的两个螺栓 (9) 和硬垫圈。
- 将泵驱动轴 (7) 放置在泵驱动装置 (4) 上。 安装将泵驱动轴 (7) 固定在泵驱动装置 (4) 上的四个螺栓 (8) 和垫圈。 拧紧螺栓至扭矩为
55 ± 7 N·m (40 ± 5 lb ft) 。Show/hide table图 3 g00650472 - 将软管组件 (6) 连接在泵驱动装置 (4) 上。
Show/hide table
图 4 g00650471 - 将软管组件 (3) 和软管组件 (5) 连接到泵驱动装置 (4) 上。
- 将护罩 (1) 放置在泵驱动轴上。 安装固定护罩 (1) 的三个螺栓 (2) 和硬垫圈。
Show/hide table
图 1 | g00650479 |
Show/hide table
图 2 | g00650480 |
结束:
- 安装齿轮泵(变速箱注油和回油)。 请参阅动力传动系的拆解和组装, "齿轮泵(变速箱注油和回油)- 安装"。
- 安装活塞泵(转向)。 请参阅拆解和组装, "活塞泵(转向)- 安装"。
- 安装齿轮泵(举升)。 请参阅拆解和组装, "齿轮泵(举升)- 安装"。
Caterpillar Information System:
2000/06/19 Special Instructions, REHS0611-01 (SI1128-01), "Installation of Axle Cooling" is Available {1365}
CS-531D, CP-533D and CS-533D Vibratory Compactors Vibratory System Vibratory Frequency - Test and Adjust
3408E and 3412E Engines for Caterpillar Built Machines Throttle Switch Circuit - Test
TH62, TH63, TH82, TH83 and TH103 Telehandlers Engine Supplement Transmission Oil Cooler - Remove
D350E Series II and D400E Series II Articulated Trucks Brakes, Indicators and Gauges - Test
776D, 777D and 777D HAA Off-Highway Trucks Machine Systems Pump Drive - Remove
D350E Series II and D400E Series II Articulated Trucks Backup Alarm - Test
3508B and 3512B Engine Supplement for 776D, 777D, and 777D HAA Tractor/Off-Highway Trucks Refrigerant Condenser - Remove and Install
IT28G Integrated Toolcarrier and 928G Wheel Loader Steering System Pressure Switch (Primary Steering Oil and Secondary Steering Oil)
776D, 777D and 777D HAA Off-Highway Trucks Machine Systems Oil Cooler (Brake) - Install
797 Off-Highway Truck Fan Drive Hydraulic System Suction Fan
TH62, TH63, TH82 and TH83 Telehandlers Transmission Neutralizer Pressure Switch - Adjust
CS-531D, CP-533D and CS-533D Vibratory Compactors Propel System Piston Pump Servo Neutral - Test and Adjust
CS-531D, CP-533D and CS-533D Vibratory Compactors Vibratory System Hydraulic Control Neutral (Piston Pump) - Test and Adjust
CB-534C and CB-634C Vibratory Compactors Steering System Steering Hydraulic System
776D, 777D and 777D HAA Off-Highway Trucks Machine Systems Pump Drive - Disassemble
797 Off-Highway Truck Fan Drive Hydraulic System Speed Sensor (Fan Drive)
CS-531D, CP-533D and CS-533D Vibratory Compactors Propel System Relief Valve (Pressure Override) - Test and Adjust
CS-531D, CP-533D and CS-533D Vibratory Compactors Vibratory System Relief Valve (Charge) - Test and Adjust
CS-531D, CP-533D and CS-533D Vibratory Compactors Vibratory System Relief Valve (Piston Pump) - Test and Adjust
797 Off-Highway Truck Fan Drive Hydraulic System Makeup Valve (Fan Motor)
CS-531D, CP-533D and CS-533D Vibratory Compactors Propel System Relief Valve (Charge) - Test and Adjust
CS-531D, CP-533D and CS-533D Vibratory Compactors Vibratory System Variable Frequency Electrical Control - Test and Adjust - If Equipped
CB-534C and CB-634C Vibratory Compactors Steering System Steering Pump