Crankshaft Front Seal - Install
安装步骤
Show/hide table
| 所需工具 | |||
|---|---|---|---|
| 工具 | 零件号 | 零件名称 | 数量 |
| A | 6V-4003 | 定位工具 | 1 |
| 2N-5006 | 螺栓 | 2 | |
| B | 6V-4977 | 安装工具 | 1 |
| 9S-8858 | 螺母 | 1 | |
Show/hide table
| 注意 |
|---|
只要从耐磨套筒上拆下曲轴密封件，就必须安装一套新的耐磨套筒和密封件。 安装用过的密封件将造成泄漏。 |
Show/hide table
| 注意 |
|---|
如果在安装时需要将曲轴密封件和耐磨套筒分开，则很难保证密封性。 请更换一套新的曲轴密封件和耐磨套筒。 |
注: 前后密封件不可互换，前后耐磨套筒也不可互换。 密封件的密封唇口上有凹槽，这些凹槽可在曲轴转动时，引导机油流回曲轴箱。 交换使用前后密封件会使机油流出曲轴箱。
- 将工具 (A) 安装到曲轴（未显示）上。
Show/hide table
 | |
| 图 1 | g00569512 |
- 将曲轴密封件 (2) 和耐磨套筒 (1) 整个安装到曲轴（未显示）上。
Show/hide table
 | |
| 图 2 | g00569516 |
- 如图所示，将工具 (B) 安装到工具 (A) 上。
Show/hide table
 | |
| 图 3 | g00569518 |
- 拧紧螺母，使曲轴密封件 (2) 和耐磨套筒 (1) 在曲轴（未显示）上处于正确位置。
End By: 安装减震器和皮带轮。 请参考 拆卸和组装, "减震器和皮带轮 － 安装"部分。
Caterpillar Information System:
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems Mode 1 - Operator Calibrations
Electric Protection System Energize-To-Run For Generator Set, Industrial and Marine Diesel Engines Engine Oil Pressure Switch Test
Electric Protection System Energize-To-Run For Generator Set, Industrial and Marine Diesel Engines Diode Test
Electric Protection System Energize-To-Run For Generator Set, Industrial and Marine Diesel Engines Magnetic Pickup Test
AP-1000B and BG-260C Asphalt Pavers Manual Propel Override Control
Digital Voltage Regulator Instantaneous Trip Shutdown - Troubleshoot
Challenger 65C, Challenger 65D, Challenger 65E, Challenger 70C, Challenger 75C, Challenger 75D, Challenger 75E, Challenger 85C, Challenger 85D, Challenger 85E and Challenger 95E Agricultural Tractors Machine Monitor System Relays
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems Service Operations
3524B Engine for Caterpillar Built Machines Accessory Drive (Rear) - Install
554 Forwarder and 574 Forwarder Gate Cylinders - Lubricate
D400E Series II Articulated Truck Hoist Control Valve - Remove
554 Forwarder and 574 Forwarder Cab Door Hinges - Lubricate
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems F342 Engine RPM Sensor - Failed High
Electric Protection System Energize-To-Run For Generator Set, Industrial and Marine Diesel Engines Slave Relay Test
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems F343 Engine RPM Sensor - Failed Low
D350E Series II Articulated Truck Power Train Rear Drive Shaft - Remove and Install
D400E Series II Articulated Truck Hoist Control Valve - Install
CP-563D, CS-563D, CS-573D and CS-583D Vibratory Compactors Vibratory System Controller (Variable Frequency) - If Equipped
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems F344 Engine RPM Sensor - Failed
3306C Engines for Caterpillar Built Machines Air Compressor
CB-534C and CB-634C Vibratory Compactors Vibratory System Vibratory System Troubleshooting
Challenger 35, Challenger 45 and Challenger 55 Agricultural Tractors Electronic Systems F345 Transmission Speed Sensor - Failed
797 Off-Highway Truck Power Train Torque Converter
3512B and 3516B Engine Supplement for and 784C,, 785C and and 785C HAA Off-Highway Truck/Tractors Engine Oil Scavenge Pump - Remove