Steering Cylinder
Show/hide table
Illustration 1 | g00849215 |
(1) Diameter of a new cylinder rod ... 50.750 ± 0.038 mm (1.9980 ± .0015 inch)
(2) Bore of a new cylinder tube ... 88.90 ± .08 mm (3.500 ± .003 inch)
(3) Bore of a new cylinder head ... 51.03 ± .03 mm (2.009 ± .001 inch)
(4) Lubricate the threads with clean grease. Torque for the cylinder head ... 600 ± 130 N·m (440 ± 95 lb ft)
(5) Lubricate the threads. Torque for the bolt ... 1125 ± 100 N·m (830 ± 75 lb ft)
(6) Lubricate the sealing lips with a minimal amount of the lubricant that is being sealed.
Steering Cylinder Drift
The maximum permissible drift per minute for the steering cylinder is 3 mm (.1 inch) at the following conditions:
- Oil temperature ... 38 to 54°C (100 to 130°F)
- Supply pressure ... 23000 kPa (3350 psi)
Caterpillar Information System:
966F Series II Wheel Loader Power Train Axle Housing - Disassemble
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0190 FMI 02 Speed Sensor (Engine) Incorrect Signal - Test
583R Pipelayer Power Train Power Train Oil Filter - Remove
143H and 163H Motor Graders All Wheel Drive Piston Pump (All Wheel Drive) - Lubricate
784C, 785C and 785C HAA Off-Highway Truck/Tractors Hydraulic System Hydraulic Components and Lines
3306C Engines for Caterpillar Built Machines Fuel Shutoff Solenoid
793C Off-Highway Truck Machine Systems Start Switch (Key) - Remove and Install
143H and 163H Motor Graders All Wheel Drive Wheel Drive - Lubricate
784C, 785C and 785C HAA Off-Highway Truck/Tractors Hydraulic System Hydraulic Components and Lines
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0855 FMI 06 Temperature Sensor (Left Rear Brake Oil) Current Above Normal - Test
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0855 FMI 04 Temperature Sensor (Left Rear Brake Oil) Voltage Below Normal - Test
5130, 5130B and 5230 Excavators, 784B, 785B, 785C, 789B, 789C, 793B and 793C Off-Highway Truck/Tractors and 992G, 994 and 994D Wheel Loaders Vital Information Management System (VIMS) CID 0855 FMI 03 Temperature Sensor (Left Rear Brake Oil) Voltage Above Normal - Test
769D Off-Highway Truck and 771D Quarry Truck Service Brakes - Inspect
143H and 163H Motor Graders All Wheel Drive General Testing and Adjusting Information
966G and 972G Wheel Loaders Changing Direction and Speed
769D Off-Highway Truck and 771D Quarry Truck Steering System Oil - Change
769D Off-Highway Truck and 771D Quarry Truck Oil Filter (Steering) - Replace
769D Off-Highway Truck and 771D Quarry Truck Steering System Oil Level - Check
550 Wheel Harvester, 570 Wheel Harvester and 580 Wheel Harvester Hydraulic System Stick Cylinder
769D Off-Highway Truck and 771D Quarry Truck Suspension Cylinder - Check
3304B and 3306B Engines for Caterpillar Built Machines Flywheel Housing - Remove and Install
CB-534C Vibratory Compactor Circuit Breakers - Reset
583R Pipelayer Power Train Power Train Oil Filter - Install
3306C Engines for Caterpillar Built Machines Fuel Shutoff Solenoid