Illustration 1 | g01101038 |
The fuse panel is located on the left side of the interior storage box. Remove the cover in order to access the fuses.
Fuses - Fuses protect the electrical system from damage that is caused by overloaded circuits. Change a fuse if the element separates. If the element of a new fuse separates, check the circuit and/or repair the circuit. |
NOTICE |
---|
Always replace fuses with the same type and capacity fuse that was removed. Otherwise, electrical damage could result. |
NOTICE |
---|
If it is necessary to replace fuses frequently, an electrical problem may exist. Contact your Cat dealer. |
To replace a fuse, use the puller that is stored in the fuse panel. One fuse of 5 Amperes, four fuses of 10 Amperes, three fuses of 15 Amperes, three fuses of 20 Amperes, two fuses of 25 Amperes, and one fuse of 30 Amperes are contained in the fuse panel as spare fuses.
The following list identifies the circuits that are protected by each fuse. The amperage for each fuse is included with each circuit.
Illustration 2 | g06310220 |
(1) Air Conditioner - 15 Amp
(2) Automatic Engine Speed Control (AEC) - 5 Amp
(3) Chassis Light - 10 Amp
(4) Cigar Lighter - 10 Amp
(5) Priming Pump - 10 Amp
(6) Switch Panel And Radio - 5 Amp
(7) Attachment Solenoid - 10 Amp
(8) Seat Heater - 5 Amp
(9) Spare - 10 Amp
(10) Window Wiper and Window Washer - 10 Amp
(11) Air Suspension Seat - 10 Amp
(12) 12 Volt 7 Amp Converter - 10 Amp
(13) Beacon - 10 Amp
(14) Inspection Lamp 1 and Camera - 10 Amp
(15) Inspection Lamp 2 - 5 Amp
(16) Alternator Regulator - 5 Amp
(17) Spare - 5 Amp
(18) Spare - 10 Amp
(19) Spare - 10 Amp
(20) Spare - 15 Amp
(21) Heater and Air Conditioner Blower Fan - 15 Amp
(22) Product Link - 5 Amp
(23) Boom Light - 10 Amp
(24) Cab Light - 10 Amp
(25) Cab Dome Light and Radio Memory - 10 Amp
(26) Engine Start Switch - 10 Amp
(27) Horn - 10 Amp
(28) Machine Control Module - 25 Amp
(29) Spare - 20 Amp
(30) Inspection Lamp 3 - 10 Amp
(31) Inspection Lamp 4 - 10 Amp
(32) Spare - 15 Amp
(33) Spare - 30 Amp
(34) Spare - 15 Amp
(35) Spare - 20 Amp
(36) Spare - 20 Amp
(37) Spare - 10 Amp
(38) Spare - 25 Amp
(39) Spare - 25 Amp
(40) Spare - 30 Amp
Illustration 3 | g06310221 |
(41) Boom Light - Relay
(42) Chassis Lamp - Relay
(43) Cab Lamp - Relay
(44) Horn - Relay
(45) Neutral Start - Relay
(46) Beacon - Relay
(47) Travel Alarm - Relay
(48) Fuel Priming Pump - Relay
Open the front access door on the left side of the machine.
Illustration 4 | g06311711 |
(A) Fuse block assembly
(1) Main relay (80 Amp) (2) Alternator (100 Amp) |
Main Breaker (1) - This fuse is to protect the electrical system. The circuit breaker has a capacity of 80 Amp.
Alternator Circuit (2) - This fuse is to protect the alternator. If the batteries are installed with reversed polarity, the circuit breaker would prevent the alternator from damaging the rectifier. The circuit breaker has a capacity of 100 Amp.