Manual Stop Procedure
Show/hide table
| 注意 |
|---|
规定恒速运转的发动机能够完成起动顺序、以单一恒速运转以及停机顺序。 对于发动机运转的每一时期，这些操作都应只出现一次。 起动顺序和停机顺序可包含短期的低怠速运转，以便加热或冷却发动机或从动设备。 排放类型审批对恒速发动机的操作（非上述操作方式）无效。 |
注: 如有配备，发动机停机前，先将"怠速/额定转速"开关设至怠速位置。
Show/hide table
| 注意 |
|---|
发动机带负荷运转后立即停机会引起过热并加快发动机零部件的磨损。 如果发动机已在高速和/或大负荷下持续运转过，使发动机停机之前，至少在低怠速运转发动机3分钟以降低和稳定发动机内部温度。 避免发动机热态停机可增加涡轮增压器轴和轴承的寿命。 |
注: 应用不同，控制系统也会不一样。 确保理解停机程序。 运用以下一般性准则以便使发动机停机。
- 从发动机上卸掉负载，使发动机功率不超过 30%。
- 以编程设定的低怠速运转发动机至少 3 分钟。
- 冷却时间结束后，把起动开关旋转到断开位置。
Caterpillar Information System:
C15 Petroleum Engines Engine Operation
C7.1-XQ200 Rental Generator Set Additional Messages
2014/10/10 Improved Cylinder Head Assemblies Are Available through Cat Reman for Certain Commercial Engines {1100}
2012/05/08 Improved Cylinder Head Assemblies Are Available through Cat Reman for Certain Machine Engines {1100}
3512C and 3516C Marine Engines Air Inlet and Exhaust Lines
2012/05/09 A New Improved Seal Is Now Used in the Reman Water Pumps of Certain Engines {1000, 1361, 7555}
2012/05/10 A New Improved Seal Is Now Used in the Reman Water Pumps in the Engines of Certain Machines {1000, 1361, 7555}
2012/05/16 A New Improved Seal Is Now Used in the Reman Water Pumps of Certain Engines {1000, 1361, 7555}
2012/05/14 New Commissioning Instructions Now Used to Ensure Correct Voltage Applied to Contactor on 3406C, C15, C18, and C9 Gen Sets {1435, 7332, 7400}
G3500 Engines Gear Group (Front)
3500C Marine Engines Alternator Mounting
3512C and 3516C Marine Engines Exhaust Bypass Valve
3512C and 3516C Marine Engines Fumes Disposal Filter
3512C and 3516C Marine Engines Exhaust Bypass Valve
3512C and 3516C Marine Engines Fumes Disposal Filter
3512C and 3516C Marine Engines Air Lines
3512C and 3516C Marine Engines Exhaust Elbow
3512C and 3516C Marine Engines Exhaust Elbow
3512C and 3516C Marine Engines Exhaust Elbow
3512C and 3516C Marine Engines Air Lines
3512C and 3516C Marine Engines Inlet Manifold Air Pressure Sensor
3512C and 3516C Marine Engines Temperature Sensor (Air Inlet) - Primary
3500 Engines for Caterpillar Built Generator Sets Air Pressure Regulator Group
G3600 A4 Engines Engine Coolant Temperature Sensor