Ensure that all of the messages are legible. Clean the messages or replace the messages if the words cannot be read or if the illustrations are not visible. Use a cloth, water, and soap for cleaning the messages. Do not use solvents, gasoline, or other harsh chemicals. Solvents, gasoline, or harsh chemicals could loosen the adhesive that secures the messages. The messages that are loosened could drop off the engine.
Replace any message that is damaged or missing. If a message is attached to a part of the engine that is replaced, install a new message on the replacement part. Your Cat dealer can provide new messages.
Illustration 1 | g02716616 |
High voltage generator set |
Illustration 2 | g02720812 |
High voltage generator set |
Illustration 3 | g02716679 |
High voltage generator set with remote control panel. |
Illustration 4 | g02716618 |
Low voltage generator set |
Illustration 5 | g02720791 |
Illustration 6 | g02717441 |
Low voltage generator set |
This safety message is located on the control panel.
Illustration 7 | g01370904 |
Do not operate or work on this equipment unless you have read and understand the instructions and warnings in the Operation and Maintenance Manual. Failure to follow the instructions or heed the warnings could result in injury or death. Contact any Cat dealer for replacement manuals. Proper care is your responsibility. |
This safety message is located on each side on the barrel of the generator. This message is located on each side of the engine near the middle. The message is also located on each side of the radiator.
Illustration 8 | g01384734 |
Hot parts or hot components can cause burns or personal injury. Do not allow hot parts or components to contact your skin. Use protective clothing or protective equipment to protect your skin. |
This safety message is located on the right and left side of the terminal box. This message is also located on the rear of the low voltage generator.
Illustration 9 | g01392482 |
Do not connect the generator to a utility electrical distribution system unless it is isolated from the system. Electrical feedback into the distribution system can occur and could cause personal injury or death. Open and secure the main distribution switch, or if the connection is permanent, install a double throw switch to prevent electrical feedback. Some generators are specifically approved by a utility to run in parallel with the distribution system and isolation may not be required. Always check with your utility for the applicable circumstances. |
This safety message is located on the right and left side of the terminal box. This message is also located on the rear of the low voltage generator.
Illustration 10 | g01392484 |
When the engine is in the AUTOMATIC mode, the engine can start at any moment. To avoid personal injury, always remain clear of the the engine when the engine is in the AUTOMATIC mode. |
This message is located on top of the radiator near the radiator cap.
Illustration 11 | g01371640 |
Pressurized System: Hot coolant can cause serious burns. To open the cooling system filler cap, stop the engine and wait until the cooling system components are cool. Loosen the cooling system pressure cap slowly in order to relieve the pressure. |
Lifting the Product (Not Including the Radiator) (6)
Illustration 12 | g01411376 |
This label is located on the right and left side of the terminal box.
Before lifting the product, read this Operation and Maintenance Manual, "Product Lifting" in the Operation Section. If improper equipment is used to lift the product, injury and damage can occur. Use cables which are properly rated for the weight. Use a spreader bar and attach the cables according to the information on the safety message. |
This safety message is located on the control panel.
Illustration 13 | g01372247 |
WARNING! Shock/Electrocution Hazard! Read and understand the instructions and warnings in the Operation and Maintenance Manual. Failure to follow the instructions or heed the warnings could cause serious injury or death. |
This safety message is located on each side of the terminal box on the low voltage generator.
Illustration 14 | g01433231 |
Crushing Hazard! Improper lifting could cause serious injury or death. Follow the lifting instructions in the Operation and Maintenance Manual for safe lifting procedures. |
Universal Warning Technical Manual (9)
This message is located on the lower panel on both sides of the dosing cabinet.
Illustration 15 | g01738913 |
Do not operate or work on this equipment unless you have read and understand the instructions and warnings in the Operation and Maintenance Manual. Failure to follow the instructions or heed the warnings could result in injury or death. Contact any Cat dealer for replacement manuals. Proper care is your responsibility. |