Battery Problem
可能原因
- 充电电路
- 蓄电池
- 辅助装置
建议的措施
按所列步骤顺序完成以上步骤。
Show/hide table
| 故障诊断与排除测试步骤 | 数值 | 结果 |
|---|---|---|
1. 充电电路 A. 检查蓄电池充电电路的工作是否正常。 请参阅故障诊断与排除, "交流发电机故障"。 |
充电电路 |
结果：充电电路不正常。 如有必要，修理充电电路。 结果：充电电路正常。 转至测试步骤 2。 |
2. 蓄电池 A. 确认蓄电池已无法保持电量。 请参阅系统操作/测试和调整, "蓄电池 - 测试"。 |
蓄电池 |
结果：蓄电池不正常。 更换蓄电池。 请参阅操作和维护手册, "蓄电池 - 更换"。 结果：蓄电池正常。 转至测试步骤 3。 |
3. 辅助装置 A. 检查是否是因为辅助装置一直处于 ON（接通）位置而耗尽了蓄电池电量。 |
辅助装置 |
结果：由于辅助装置一直处于接通位置，蓄电池被耗尽。 向蓄电池充电。 确认蓄电池能够保持电量。 参考系统操作/测试和调整以了解正确步骤。 结果：辅助装置一直处于接通位置，但蓄电池未被耗尽。 请联系代理商解决方案网络 (DSN)。 |
Caterpillar Information System:
C3.4B Engines Alternator Problem - Charging Problem and/or Noisy Operation
C6.6 Industrial Engine Flywheel Housing - Flywheel Housing that is Equipped with Rear Power Take-Off
C4.4 Industrial Engine Fuel Filter Base - Primary Fuel Filter Base
C1.5 and C2.2 Industrial Engines California Emission Control Warranty Statement
C1.5 and C2.2 Industrial Engines Federal Emission Control Warranty
C1.5 and C2.2 Industrial Engines Reference Material
3516C Generator Sets Fuel System Primary Filter (Water Separator) Element - Replace
EMCP4.1/EMCP4.2 Custom Text String Is Not Shown
EMCP4.1/EMCP4.2 Custom Event Is Not Present
3516C Generator Sets Engine Air Cleaner Element (Dual Element) - Inspect/Clean/Replace
CX31 On-Highway Transmission Transmission Planetary - Assemble - Retarder
CX31 On-Highway Transmission Transmission Planetary - Disassemble - Retarder
C3.4B Engines Coolant Contains Oil
2010/10/20 A New Camshaft Thrust Washer and Plate Are Used in C175-16 Generator Set Engines {1210, 1210, 7553}
C3.4B Engines Coolant Temperature Is High
C3.4B Engines Cylinder Is Noisy
C175-16 Locomotive Engine Engine Oil Pressure - Test
C27 and C32 Industrial Engines Rear Power Take-Off (RPTO) - Install
320 VH and VM Variable Gauge Undercarriage Track Carrier Roller - Remove and Install - VM Undercarriage
G3500 A3 Engines Coolant Pressure Is High
G3500 A3 Engines Coolant Pressure Is Low
C9.3 Tier 4 Final Engines Electric Starting Motor
C3.4B Engines Electronic Service Tool Does Not Communicate
C3.4B Engines Engine Does Not Crank