Pistons and Connecting Rods - Remove
Show/hide table
所需工具 | |||
---|---|---|---|
工具 | 零件号 | 零件描述 | 数量 |
A | 9S-9082 | 发动机盘车工具 | 1 |
开始:
- 拆下缸盖。 请参阅拆解和组装, "缸盖 - 拆卸"。
- 拆下活塞冷却喷嘴。 请参阅拆解和组装, "活塞冷却喷嘴 - 拆卸和安装"。
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损並縮短部件使用寿命。 |
- 用工具 ( A) 旋转曲轴,直到活塞处于底部中央位置。
- 从缸套内表面顶部开始清除积碳凸起。
- 检查连杆和连杆盖上的识别标记是否正确。 连杆和连杆盖侧面应该有蚀刻的编号。 该编号必须与气缸号一致。 如有必要,标记连杆和连杆盖。
注: 请勿压印连杆组件。 在连杆组件上压印或冲孔会导致连杆断裂。
- 拆下螺栓 (1) 和连杆轴承盖 (2)。
Show/hide table
图 2 g01149595 - 将活塞 (3) 和连杆从缸套中拆下。
Show/hide table
图 1 | g01149594 |
Caterpillar Information System:
986H Wheel Loader Starting System - Test
D6K2 Track-Type Tractor TA2 Technical Inspection{0372, 1000, 7000, 753T, 7565} D6K2 Track-Type Tractor TA2 Technical Inspection{0372, 1000, 7000, 753T, 7565}
C32 Marine Engines Piston Cooling Jets - Remove and Install
C32 Marine Engines Cylinder Liner - Install
D8R and D8T Track-Type Tractors Battery Disconnect Switch
Field Installation Instructions for the Variable Pitch Fan System on 980K Wheel Loaders{1071, 107P, 1356, 1386, 138R, 7620} Field Installation Instructions for the Variable Pitch Fan System on 980K Wheel Loaders{1071, 107P, 1356, 1386, 138R, 7620}
C32 Marine Engines Cylinder Liner - Remove
374F Excavator Additional Messages
2012/10/24 A New Water Temperature Regulator Is Available for Certain Commercial Engines {1355}
826K Landfill Compactor Belt - Inspect/Adjust/Replace
C32 Marine Engines Camshaft Bearings - Install
C32 Marine Engines Camshaft Bearings - Remove
C32 Marine Engines Pistons and Connecting Rods - Install
C32 Marine Engines Pistons and Connecting Rods - Disassemble
C32 Marine Engines Pistons and Connecting Rods - Assemble
C32 Marine Engines Inlet and Exhaust Valve Guides - Remove and Install
2012/10/03 A New Valve Lifter Assembly Is Used in 3500B Engines {1209}
2012/10/30 A New Valve Lifter Assembly Is Used in 3500B and 3500C Engines {1209}
C32 Marine Engines Engine Oil Filter Base - Disassemble
2012/10/03 Importance of Proper Valve Lash Setting {1102, 1121, 1123, 1209}
2012/10/04 Importance of Proper Valve Lash Setting {1102, 1121, 1123}
Installation Procedure for the 423-5844 Conversion Kit {5057, 5147, 5734, 6129, 7332} Installation Procedure for the 423-5844 Conversion Kit {5057, 5147, 5734, 6129, 7332}
C32 Marine Engines Engine Oil Filter Base - Assemble
Procedure to Configure VIMS 3G® On Certain Cat® Products {7601} Procedure to Configure VIMS 3G® On Certain Cat® Products {7601}