Diesel Particulate Filter Active Regeneration Occurrence Is Excessive
注: 此步骤只适用于配备有壁流柴油微粒滤清器(DPF)和 DPF 压差传感器的发动机。
DPF 的主动再生将会被电子控制模块(ECM)中计算的烟尘模型正常激活。 如果通过 DPF 的差压过高,ECM 将根据 DPF 差压激活主动再生。
可能原因
- 排气管上的绝缘层(如有配备)
- 诊断代码
- 保养时间表
- 低压缩(气缸压力)
- 电子单体喷油器
- 单个故障气缸
建议的措施
注: 下面以概率的先后顺序列出了这些步骤。 依次完成这些步骤。
Show/hide table
故障诊断与排除测试步骤     | 数值     | 结果     |
---|---|---|
1. 排气管上的绝缘层(如有配备) A. 检查发动机和清洁排放模块(CEM)之间排放管上的绝缘层。 确保绝缘层没有缺失或损坏。     |
代码     |
结果:绝缘层缺失或损坏。 修理或更换绝缘层。 结果:绝缘层正常。 转至测试步骤 2。     |
2. 诊断代码 A. 将电子维修工具连接到诊断接头上。 B. 检查有无现行诊断代码。 C. 使用电子维修工具执行维修再生。 D. 在电子维修工具上检查有无激活的诊断代码。     |
诊断代码     |
结果:存在激活的诊断代码。 在继续执行本步骤之前,调查所有现行代码。 请参阅故障诊断与排除, "故障诊断代码"。 结果:无现行诊断代码。 转至测试步骤 3。     |
3. 保养时间表 A. 检查 DPF 的保养时间表。 请参阅操作和保养手册, "保养周期表"。     |
保养时间表     |
结果:DPF 应该要进行灰分维修。 执行灰分维修。 请参阅操作和保养手册, "柴油微粒滤清器 - 清洁"。 结果:DPF 不用进行灰分维修。 继续测试步骤 4。     |
4. 低压缩(气缸压力) A. 执行压缩测试。 请参阅系统操作、测试和调整, "压缩 - 测试"。     |
压缩压力低     |
结果:记录了一缸或多缸上的压缩压力低。 压缩压力低的可能原因如下所列: · 预热塞松动 · 活塞故障 · 活塞环故障 · 缸径磨损 · 气门磨损 · 缸盖密封垫故障 · 缸盖损坏 根据需要进行修理。 结果:未发现故障。 继续测试步骤 5。     |
5. 单个故障气缸 A. 发动机处于高怠速转速时,使用电子维修工具执行手动"断缸测试"。 每个气缸切断时,倾听发动机声音的变化。 当气缸切断时,发动机声音应有明显不同。     |
气缸     |
结果:至少有一缸的发动机声音没有明显不同。 调查所有未工作气缸的故障原因。 调查所有性能低于正常值的工作气缸的故障原因。 结果:各缸的发动机声音均有明显不同。 请联系代理商解决方案网络 (DSN)。     |
Caterpillar Information System:
D8T Track-Type Tractor Machine Systems Refrigerant Condenser
D6T Track-Type Tractor Machine Systems including Specifications Tilt Cylinder (Bulldozer)
C27 and C32 Engines for Caterpillar Built Machines Turbocharger
D6T Track-Type Tractor Machine Systems including Specifications Lift Cylinder (Bulldozer) - VPAT
D6T Track-Type Tractor Machine Systems including Specifications Angle Cylinder (Bulldozer)
D6T Track-Type Tractor Machine Systems including Specifications Lift Cylinder (Bulldozer)
D6T Track-Type Tractor Machine Systems including Specifications Piston Motor (Fan Drive)
D6T Track-Type Tractor Machine Systems including Specifications System Pressure
D6T Track-Type Tractor Machine Systems including Specifications Control Manifold - Pilot
D6T Track-Type Tractor Engine including Specifications Flywheel Housing
D6T Track-Type Tractor Machine Systems including Specifications Control Manifold
D6T Track-Type Tractor Machine Systems including Specifications Fan Reversing Valve
Procedure to Restore Sprocket Shaft Bores in Oval Track-Type Machines{4058, 4164, 4184} Procedure to Restore Sprocket Shaft Bores in Oval Track-Type Machines{4058, 4164, 4184}
D8T Track-Type Tractor Machine Systems Engine Enclosure
2011/01/06 The Oscillation Angle for the Equalizer Bar Is Now Controlled on D6G Track Type Tractors {7206}
Carrier Roller Oil Fill Volume {4154} Carrier Roller Oil Fill Volume {4154}
Welding Wire and Flux {0679, 4150, 7950} Welding Wire and Flux {0679, 4150, 7950}
D8T Track-Type Tractor Charge Pump
992K Wheel Loader Machine Systems Brake Control Valve (Parking) - Remove and Install
D8T Track-Type Tractor Hydraulic System Bulldozer Tilt Control Valve
D8T Track-Type Tractor Hydraulic System Ripper Tilt Control Valve
966M and 972M Wheel Loaders Power Train, Steering, Braking, Hydraulic & Machine Systems Governor Pedal
992K Wheel Loader Machine Systems Pilot Oil Accumulator - Remove and Install
D7E Track-Type Tractor Power Train Systems General Information