525C, 535C and 545C Wheel Skidders Caterpillar

Fuel System - Prime

Usage:

525C 525

Turn the engine start switch to the ON position. Leave the engine start switch in the ON position for two minutes.

Attempt to start the engine. If the engine starts and the engine runs rough or the engine misfires, operate at low idle until the engine is running smoothly. If the engine cannot be started, or if the engine continues to misfire or smoke, repeat step 1.

Note: The electric fuel pump turns on when the key is turned on. There is not a separate priming pump.

Caterpillar Information System:

631G and 637G Wheel Tractor-Scrapers Engine Supplement Fan - Remove and Install

C27 and C32 Engines Piston Ring Groove - Inspect

988H Wheel Loader Braking System Brake System Troubleshooting

C15 and C18 Engines for Caterpillar Built Machines Flywheel Housing

613C Series II Wheel Tractor-Scraper Cooling System Coolant Sample (Level 2) - Obtain

613C Series II Wheel Tractor-Scraper Cooling System Coolant Sample (Level 1) - Obtain

834H Wheel Dozer and 836H Landfill Compactor Electrohydraulic System Main Hydraulic System

D9T Track-Type Tractor Machine Systems Steering Oil Filter and Base - Assemble

AD30 Underground Articulated Truck Transmission to Output Transfer Gears - Connect

AD55 Underground Articulated Truck Power Train Transmission Hydraulic Control Clutch Pressure - Test

2004/08/02 Correction to Specifications , "Gear Pump (Hoist, Steering, Brake, and Pilot)" {4268, 4306, 5073, 5083, 5085}

930H Wheel Loader Hydraulic System Hydraulic Oil Contamination - Test

525C, 535C and 545C Wheel Skidders Fuel System Primary Filter (Water Separator) - Drain

525C, 535C and 545C Wheel Skidders Fuel System Primary Filter (Water Separator) Element - Replace

D9T Track-Type Tractor Machine Systems Implement Control Valve - Disassemble

525C, 535C and 545C Wheel Skidders Fuel Tank Cap and Strainer - Clean

Repairing Track Roller Frames{4151} Repairing Track Roller Frames{4151}

2005/01/10 New Triten Bucket Wear Plates Are Available {6120}

525C, 535C and 545C Wheel Skidders Engine Oil Level - Check

C27 and C32 Engines for Caterpillar Built Machines Electric Starting System - Test

631G and 637G Wheel Tractor-Scrapers Engine Supplement Muffler - Remove and Install

623E Wheel Tractor-Scraper Hydraulic System Hydraulic Tank and Filter

525C, 535C and 545C Wheel Skidders Ether Starting Aid Cylinder - Replace - If Equipped

525C, 535C and 545C Wheel Skidders Battery Hold-Down - Tighten