3056E Industrial Engine Caterpillar


Valve Guide - Inspect

Usage:

3056E 356
Perform this test in order to determine if a valve guide should be replaced.


    Illustration 1g00314806
    Measure the radial movement of the valve in the valve guide.
    (1) Valve guide
    (2) Radial movement of the valve in the valve guide
    (3) Valve stem
    (4) Dial indicator
    (5) Valve head

  1. Place a new valve in the valve guide.

  2. Place a dial indicator with a magnetic base on the face of the cylinder head.

  3. Lift the edge of the valve head to a distance of 15.0 mm (0.60 inch).

  4. Move the valve in a radial direction away from the dial indicator. Make sure that the valve moves away from the dial indicator as far as possible. Position the contact point of the dial indicator on the edge of the valve head. Set the position of the needle of the dial indicator to zero.

  5. Move the valve in a radial direction toward the dial indicator as far as possible. Note the distance of movement which is indicated on the dial indicator. If the distance is greater than the maximum clearance of the valve in the valve guide, replace the valve guide.

    The maximum clearance for the inlet valve stem in the valve guide with a valve lift of 15.0 mm (0.60 inch) is the following value. ... 0.100 mm (0.0039 inch)

    The maximum clearance for the exhaust valve stem in the valve guide with a valve lift of 15.0 mm (0.60 inch) is the following value. ... 0.121 mm (0.0048 inch)

When new valve guides are installed, new valves and new valve seat inserts must be installed. Valve guides and valve seat inserts are supplied as an unfinished part. The unfinished valve guides and unfinished valve seat inserts are installed in the cylinder head. Then, the valve guides and valve inserts are cut and reamed in one operation with special tooling.

Refer to Disassembly and Assembly, "Inlet and Exhaust Valve Guides - Remove and install" for the replacement of the valve guides.

Caterpillar Information System:

Installation of Valves that Improve the Hydraulic Fan System and the Pilot System{1387, 5051, 5057, 5059} Installation of Valves that Improve the Hydraulic Fan System and the Pilot System{1387, 5051, 5057, 5059}
AD30 Underground Articulated Truck Cab Air Filter - Clean/Replace - If Equipped
AD30 Underground Articulated Truck Braking System - Test
AD30 Underground Articulated Truck Jacking Locations
R2900 Load Haul Dump Engine Valve Lash - Check/Adjust
AD45 and AE40 II Underground Articulated Trucks Lubricant Viscosities
AD45 and AE40 II Underground Articulated Trucks Tire Shipping Pressure
621G Wheel Tractor-Scraper Engine Air Filter Secondary Element - Replace
AD45 and AE40 II Underground Articulated Trucks Parking Brake Manual Release
627G Wheel Tractor-Scraper Engine Air Filter Service Indicator - Inspect
623G Wheel Tractor-Scraper Additional Messages
651B and 657B Wheel Tractor-Scrapers with a C15 Engine Tier III Repower Engine Air Filter Secondary Element - Replace
2002/12/16 Correction to Special Instruction , "Installation of 3-Bolt Idler Caps" {4165}
D5N Track-Type Tractor Power Train Steering Clutch and Brake Control Valve - Remove
D5N Track-Type Tractor Power Train Steering Clutch and Brake Control Valve - Install
2003/01/06 A New Assembly Procedure will Prevent the Hydraulic Oil Filter Base from Loosening {5068}
AD30 Underground Articulated Truck Cooling System Coolant (DEAC) - Change
2002/12/23 Washer Pump Assemblies Must Be Primed Properly {7306}
2003/01/20 Kits are Available for Servicing 105-4324 Air Starting Motor Gp {1451}
AD45 and AE40 II Underground Articulated Trucks Filter and Screen Locations
AD30 Underground Articulated Truck Cooling System Coolant (ELC) - Change
3056E Industrial Engine Cylinder Head
AD45 and AE40 II Underground Articulated Trucks Sampling Interval and Location of Sampling Valve
D5N Track-Type Tractor Power Train Track Carrier Roller - Install
Back to top
The names Caterpillar, John Deere, JD, JCB, Hyundai or any other original equipment manufacturers are registered trademarks of the respective original equipment manufacturers. All names, descriptions, numbers and symbols are used for reference purposes only.
CH-Part.com is in no way associated with any of the manufacturers we have listed. All manufacturer's names and descriptions are for reference only.