Fuel Shutoff Solenoid
Show/hide table
| |
| Illustration 1 | g00527991 |
(1) Solenoid
Solenoid
- Type ... Push
- Duty ... Continuous
- Operating voltage ... 24 to 32 VDC
- Coil resistance at a temperature of 25 °C (77 °F) ... 37.8 to 46.2 ohms
- Duty ... Continuous
(2) Mounting bolts
- Torque ...
10 ± 1 N·m (89 ± 9 lb in)
(3) Locknut
- Torque ...
68 ± 7 N·m (50 ± 5 lb ft)
(4) Setscrew
(5) Lever
(6) Housing
(7) Gasket
(8) Plunger
Use the following procedure to adjust the plunger.
- Hold housing (6) against gasket (7) on a flat surface.
- Adjust setscrew (4) clockwise until the setscrew contacts the surface of lever (5).
- Turn setscrew (4) counterclockwise.
Number of turns ... 1/4 turn
- Energize solenoid (1). Turn the solenoid clockwise until the solenoid stops.
- Turn the solenoid clockwise.
Number of turns ... 1/4 turn
- Tighten the locknut (3).
Caterpillar Information System:
3412E, C30 and C32 Marine Engines Flash Codes
3500 Engines Electrical Gauge - Test - Water Temperature
2002/04/01 Correction To Disassembly And Assembly, RENR1333-01, "3618 Engine" {1102}
3406E, C-10 and C-12 Truck Engines Engine Operation
3406E, C-10 and C-12 Truck Engines Starting the Engine
3126E Truck Engine Exhaust Particulate Filter - Assemble
3406E, C-10 and C-12 Truck Engines Engine Operation with Intermittent Diagnostic Codes
3406E, C-10 and C-12 Truck Engines Engine Operation with Active Diagnostic Codes
797B Off-Highway Truck Hydraulic System Pad Assembly (Truck Body) - Install and Adjust
3500 Generator Set Engines Air Shutoff Solenoid
3406E, C-10 and C-12 Truck Engines Diagnostic Flash Code Retrieval
3500 Engines Temperature Contactor - Test
2002/08/01 The New 216-7919 Gasket Is Available {1071}
3406E, C-10 and C-12 Truck Engines Cylinder Head Grounding Stud - Inspect/Clean/Tighten
3406E, C-10 and C-12 Truck Engines Engine Oil Level - Check
3406E, C-10 and C-12 Truck Engines Engine Oil Level Gauge - Calibrate
C-9 Engine for TK711, TK721, TK722, TK732, TK741, TK751, and TK752 Track Feller Bunchers Injection Actuation Pressure Sensor - Test
3406E, C-10 and C-12 Truck Engines Engine Oil and Filter - Change
3412E, C30 and C32 Marine Engines CID 0177 FMI 03 Transmission Oil Temperature open/short to +batt
3412E, C30 and C32 Marine Engines CID 0177 FMI 04 Transmission Oil Temperature short to ground
3500 Industrial Engine Attachments Electrical Gauge - Test - Engine Oil Pressure
2002/04/01 A New Cylinder Liner Is Available {1216}
G3500B Engines Cooling System - Power Module
3406E, C-10 and C-12 Truck Engines Fuel System - Prime