Engine Oil Pump - Remove
Show/hide table
所需工具 | |||
工具 | 零件号 | 零件描述 | 数量 |
A | 138-7573 | 连杆支架 | 1 |
B | 5J-0490 | 螺栓 | 2 |
Show/hide table
热油和热的部件可能会导致人身伤害。 不要使热油或热的部件与皮肤接触。 在执行任何维修工作前,请确保发动机和部件得到充分冷却,以便可以和裸手接触。 |
Show/hide table
注意 |
---|
保持所有零件清洁无杂质。 杂质会造成快速磨损並縮短部件使用寿命。 |
Show/hide table
注意 |
---|
在检查、保养、测试、调整及维修产品时,请小心确保盛接油液。 在打开任何舱室或拆卸任何含有油液的部件前,请准备好盛接液体用的适当容器。 |
- 拆下将法兰 (2)和隔套 (1)固定到发动机油泵 (4)上的螺栓。 拆下隔套 (1)。
- 拆下法兰 (2)。
- 拆下将三通管 (3)固定到发动机油泵 (4)上的螺栓。 从三通管 (3) 上拆卸 O 形密封圈。
- 将工具 (A) 和适当的起吊设备连接到发动机油泵 (4) 上。 发动机机油泵 (4) 的重量约为
104 kg (230 lb) 。 - 拆掉把发动机油泵 (4) 固定到前壳体上的螺栓。
- 将工具 (B)安装在发动机油泵 (4)内。 用力均匀地拧紧工具 (B),并拆下发动机油泵 (4)。
- 从前壳体上卸下 O 形密封圈。
- 将 O 形密封圈从发动机油泵上拆下。
Show/hide table
图 1 | g01303921 |
Caterpillar Information System:
G3612 and G3616 Engines Lubrication Metering Pump - Remove and Install
Generator Set Load Sensor Phasing - Check
G3612 and G3616 Engines Fuel Lines - Remove and Install
3612 and 3616 Engines Prelubrication Oil Pump - Assemble
3612 and 3616 Engines Prelubrication Oil Pump - Disassemble
Generator Set Load Sensor System Operation
3500B Locomotive Engines Overspeed Verify Switch
3612 and 3616 Engines Prelubrication Oil Pump - Install
3612 and 3616 Engines Prelubrication Oil Pump - Remove
3406E Truck Engine Inlet Manifold Pressure - Test
G3612 and G3616 Engines Prelubrication Oil Pump - Remove
3126B Marine Engine Monitoring System
3406E and 3456 Engines for Caterpillar Built Machines Fuel System - Prime
3500B Locomotive Engines Injector Solenoids
3034 Engine for Caterpillar Built Machines Engine Oil Pressure
3114, 3116 and 3126 Engines Fuel Transfer Pump
3176B Marine Engine Cold Weather Starting
3500B Locomotive Engines Start/Run/Stop Switch
Generator Set Load Sensor Engine Does Not Share Load - Troubleshoot
3408E and 3412E Engines for Caterpillar Built Machines Fuel System Pressure - Test
C15 and C18 Petroleum Generator Sets Diagnostic Lamp
3512 and 3516 EUI Engines for 784B, 785B, 789B and 793B Off-Highway Trucks Engine Overspeeds on Start-up
C27 and C32 Engines Electronic Unit Injector - Test
C15 Petroleum Generator Set Engines Gear Group (Front) - Time