Illustration 1 | g01962341 |
Location of the electrical panel or the fuses, the circuit breakers, and the relays |
The electrical panel for the fuses, the circuit breakers, and the relays is positioned behind the seat on the right rear of the operator station.
Illustration 2 | g01919410 |
NOTICE |
---|
If it is necessary to replace fuses frequently, an electrical problem may exist. Contact your Cat dealer. |
NOTICE |
---|
Always replace fuses with the same type and capacity fuse that was removed. Otherwise, electrical damage could result. |
Fuses protect the electrical system from damage that is caused by overloaded electrical circuits. Replace a fuse if the element separates. If the fuse of a particular electrical system requires frequent replacement, check the electrical circuit. Repair the electrical circuit, if necessary. Use the tool that is stored on the electrical panel in order to remove the fuses.
Spare Fuse (A) - 12 V with connector |
Radio (1) - 20 Amp |
MineStar (2) - 15 Amp |
12 Volt Power Port (3) - 15 Amp (Dash panel) |
12 Volt Power Port (4) - 15 Amp (Rear panel) |
Communication Radio (5) - 20 Amp (Prewired harness in the headliner) |
Cigar Lighter (6) - 15 Amp |
CB Radio (7) - 15 Amp (Prewired Harness in the rear panel) |
Entertainment Radio (Memory) (8) - 15 Amp |
Spare Fuse (B) - 24 V with connector |
Window Washer and Wiper (9) - 20 Amp |
Air Dryer (10) - 15 Amp |
Air Start System (11) - 20 Amp |
Air Seat (12) - 20 Amp (Operator) |
Work Lights (13) - 15 Amp |
Heated Mirror (14) - 20 Amp (Right mirror and front mirror) |
Air Seat (15) - 20 Amp (Passenger) |
Cab Air Cleaner (16) - 20 Amp |
Heated Mirror (17) - 20 Amp (Left mirror) |
Autolube System (18) - 20 Amp |
Chassis Power (19) - 10 Amp |
Fog Lights (20) - 20 Amp |
Electronic Engine Thermostat (21) - 15 Amp |
Camera Lights (22) - 20 Amp |
WAVS (23) - 15 Amp |
VIMS 3G (24) - 15 Amp |
Product Link (25) - 15 Amp |
Brake ECM (26) - 20 Amp |
Engine ECM (27) - 20 Amp |
Keyswitch (28) - 10 Amp |
HVAC Water Valve (29) - 20 Amp |
Stairway Access Lights (30) - 20 Amp |
Horn (31) - 10 Amp |
Chassis ECM (32) - 20 Amp |
24 Volt to 12 Volt Converter (33) - 20 Amp |
Drive Train ECM (34) - 20 Amp |
Gauge Cluster, Advisor Display, Retarder Lever Sensor (35) - 10 Amp |
Interior Service Tool Port (36) - 15 Amp |
Illustration 3 | g01919409 |
Push in the button in order to reset the circuit breaker. If the electrical system is working properly, the button will remain depressed. If the button does not remain depressed, check the appropriate electrical circuit. Repair the electrical circuit, if necessary. Use the tool that is stored on the electrical panel in order to remove the circuit breakers.
Note: The circuit breakers for the low beam headlights, the high beam headlights, and the fog lights are automatic reset circuit breakers.
Spare Circuit Breaker (C) - 24 V with connector |
Brake Retraction Motor (37) - 20 Amp |
High Speed Blower (38) - 20 Amp |
Headlights (39) - 15 amp |
Air Conditioner Compressor (40) - 20 Amp |
Power Window (Left) (41) - 20 Amp |
Power Window (Right) (42) - 20 Amp |
Fuel Priming Pump / Fuel Control Valve (43) - 15 Amp |
Illustration 4 | g01919407 |
A relay is an electrical switch that opens and closes under the control of another electrical circuit. Use the tool that is stored on the electrical panel in order to remove the relays.
Spare Relay (D) - 24 V with connector |
Drive Train Lamp (44) |
Stop Lamp (45) |
Headlight (46) |
Autolube (47) |
Idle Shutdown Timer (48) |
VIMS Green Lamp (49) - Payload |
VIMS Red Lamp (50) - Payload |
Horn (51) |
Rear Camera Lights (52) |
Engine Lockout (53) |
Window Wiper (54) - Slow/Intermittent |
Window Wiper (55) - High |
Window Washer (56) |
Cab Air Cleaner (57) |
Fuel Priming Pump / Fuel Control Valve (58) |
Engine Prelube (59) |
VIMS Blue Lamp (60) - Service Light |
Rear Window Wiper (61) |
Engine Lockout Lamp (62) |
Front Camera (63) - WAVS |
Air Conditioner Clutch (64) |
Backup Alarm (65) |
Illustration 5 | g02779037 |
(66) Fuse and Relay Block
(67) Fuse Block (68) Circuit Breaker |
Main Power (68) |
Illustration 6 | g03338557 |
Ethernet Switch 1 (69) - 10A |
Ethernet Radio (70) - 10A |
Ethernet Router (71) - 10A |
Light Detection and Ranging (Lidar) Sensor (72) - 15A |
Ethernet Switch 2 (73) - 10A |
Ethernet Switch 3 (74) - 10A |
Cabinet Fan (75) - 30A |
Global Positioning System (GPS) (76) - 15A |
Horn and head lamp (77) - 10A |
Key Start Switch (78) - 10A |
Ethernet Switch 4 (79) - 10A |
12 Volt Primary Convertor (80) - 10A |
12 Volt Secondary Convertor (81) - 10A |
Autonomous Electronic Control Module (ECM) 5 (82) - 10A |
Autonomous ECM 2 (83) - 15A |
Autonomous ECM 1 (84) - 15A |
Autonomous ECM 4 (85) - 15A |
Autonomous ECM 3 (86) - 15A |
Machine - ECM Master 1 (87) - 10A |
Machine - ECM Slave 2 (88) - 15A |
Backup Battery 1 (89) - 15A |
Backup Battery 2 (90) - 15A |
Secondary Steering ECM (91) - 15A |
Service Brake Pressure Sensor (92) - 10A |
Router (93) - 10A |
Turn Signal - Right (94) |
Turn Signal - Left (95) |
Horn (96) |
Headlamp (97) |
Key Start Switch (98) |
Illustration 7 | g03338559 |
Left and Middle Radars 1 (99) - 10A |
Right Radars 2 (100) - 10A |
Rear Radars 3 (101) - 10A |
Radars Key Switch (102) - 102 |
ABS Internal Measuring Unit and Tire Monitoring System (TMS) (103) - 10A |
USB Drive (104) - 10A |
Pulse Per Second Buffer (105) - 10A |
Left-hand Autonomous Stop Receiver 1 (106) - 10A |
Right-hand Autonomous Stop Receiver 2 (107) - 10A |