The Mounting Clamp of the Accumulator Group is Breaking on Certain 797B and 797F Off-Highway Trucks{4331}
- Off-Highway Truck:
- 797B (S/N: JSM1-UP)
- 797F (S/N: LAJ1-UP; WSP1-UP)
Introduction
The problem that is identified in the technical information bulletin that follows does not have a known permanent solution. Until a permanent solution is known, use the solution that is identified below.
Problem
Show/hide table
Illustration 1 | g03294198 |
The top 255-0781 Clamp (1) is cracking near the mounting bolt holes. The 255-0781 Clamp is part of the 255-7765 Steering Accumulator and Mounting Gp and 333-1456 Hydraulic Accumulator and Mounting Gp . The failed clamp results in a loose accumulator group.
Solution
Replace with the same 255-0781 Clamp . Inspect the clamp regularly and replace as required.
Caterpillar Information System:
CB44B Vibratory Asphalt Compactor Propel System (Solid Drum) Hydraulic Schematic (Propel System) - Solid Drum
745 Articulated Truck Aftercooler Core - Inspect/Clean
C1.5 and C2.2 Engines for Caterpillar Built Machines Exhaust Has Excessive Black Smoke
CB44B Vibratory Asphalt Compactor Propel System (Solid Drum) Electrical Schematic (Propel System) - Solid Drum
826K Landfill Compactor Brake Accumulator - Check
C1.5 and C2.2 Engines for Caterpillar Built Machines Engine Vibration Is Excessive
559C and 579C Knuckleboom Loaders Solenoid Valve and Manifold - Thermal Bypass
521B and 522B Track Feller Bunchers Engine Supplement Unit Injector Hydraulic Pump - Remove and Install
C1.5 and C2.2 Engines for Caterpillar Built Machines Engine Stalls at Low RPM
826K Landfill Compactor Battery Hold-Down - Tighten
2013/02/28 New HE Check Valve is Now Available on Certain Medium Wheel Loaders {5004, 5054, 5066, 5067}
Alternator - Bosch K1/N1 Insulated Screw - Check
826K Landfill Compactor Belt - Inspect/Adjust/Replace
2012/10/24 A New Water Temperature Regulator Is Available for Certain Commercial Engines {1355}
2013/02/25 A New Insulated Support Assembly is Now Used on 773G and 775G Off-Highway Trucks {7257}
2012/12/10 A New Mud Guard in the Fender Group Is Now Used on Certain 773G and 775G Quarry Trucks {4220, 7252}
2012/10/23 New Permanent Coupling Assemblies Are Now Used for the Service Brake Group on 773G and 775G Quarry Trucks {4251}
CB-634D Paving Compactor Lubricant Viscosities
2012/10/03 A New Valve Lifter Assembly Is Used in 3500B Engines {1209}
2012/10/30 A New Valve Lifter Assembly Is Used in 3500B and 3500C Engines {1209}
559C and 579C Knuckleboom Loaders General Information (Stabilizer System)
2012/10/03 Importance of Proper Valve Lash Setting {1102, 1121, 1123, 1209}
2012/10/04 Importance of Proper Valve Lash Setting {1102, 1121, 1123}
Procedure to Configure VIMS 3G® On Certain Cat® Products {7601} Procedure to Configure VIMS 3G® On Certain Cat® Products {7601}