MID 161 - CID 0590 - FMI 14
Conditions Which Generate This Code:
This diagnostic code is recorded when the software is not matched between two electronic control modules (ECMs). One ECM may have been updated and another ECM may need updating.
System Response:
This failure results in events logged against the VIMSTM 3G Main ECM that cannot be explained. The VIMS 3G Main ECM cannot communicate correctly with the Engine ECM.
Test Step 1. Flash Software
- Flash the correct software to both ECMs.
See Testing and Adjusting, "Electronic Control Module (ECM) - Flash Program".
Results:
- OK - STOP
Caterpillar Information System:
854K Wheel Dozer and 992K, 993K Wheel Loaders VIMSTM 3G / Product Link Using Advisor to Determine Diagnostic Codes
784C, 785B, 785C, 785D, 789B, 789C, 789D, 793B, 793C, 793D, 797 and 797B Off-Highway Trucks VIMS ™ Emerging Symptom Information
784C, 785B, 785C, 785D, 789B, 789C, 789D, 793B, 793C, 793D, 797 and 797B Off-Highway Trucks VIMS ™ Symptom Troubleshooting
Landfill Compactors, Soil Compactors, Wheel Dozers, and Wheel Loaders VIMSTM 3G General Information
2011/09/19 A New Tube As Within the Transmission Oil Lines Group is Now Available for Certain Motor Graders {3016, 3154}
Engine Oil Pressure Gauge on Monitoring System Can Appear to Indicate Oil Pressure Too Low{7450, 7490, 7620} Engine Oil Pressure Gauge on Monitoring System Can Appear to Indicate Oil Pressure Too Low{7450, 7490, 7620}
2012/05/02 New Fuel Tank Assemblies Are Now Used on 793F Off-Highway Trucks {1273}
120M Series 2 Motor Grader Engine Supplement Combustion Head - Remove and Install
2011/10/28 An Improved Platform Assembly is Now Used in the Platform Group on 793F Off-Highway Trucks {7253}
2011/10/12 Service Replacement Bolts and Seal Washers Are Available for the High-Pressure Fuel Pump on C175 Off-Highway Truck Engines {1251, 1290, 7553}
3516B and 3516C Engines for 789D Off-Highway Trucks Shutdown (Ground Level) - Test
C3.4B Engines Inlet Air Is Restricted
854K Wheel Dozer and 992K, 993K Wheel Loaders VIMSTM 3G / Product Link Power Supply Circuit of Electronic Control Module
C18 Generator Set Product Description
C15 and C18 Petroleum Generator Sets Alarms and Shutoffs
R1600H Load Haul Dump Tilt Linkage Bearings - Lubricate
R1600H Load Haul Dump Tilt Cylinder and Tilt Lever Bearings - Lubricate
R1600H Load Haul Dump Tire Inflation - Check
R1600H Load Haul Dump Transmission Mounts - Inspect
R1600H Load Haul Dump Transmission Oil - Change
R1600H Load Haul Dump Transmission Oil Filter - Replace
R1600H Load Haul Dump Transmission Oil Level - Check
R1600H Load Haul Dump Window Washer Reservoir - Fill
R1600H Load Haul Dump Window Wiper - Inspect/Replace - If Equipped