CB54 and CB64 Vibratory Asphalt Compactors Caterpillar

Engine Air Filter Service Indicator - Inspect

Usage:

CB-64 CB5

The air filter element indicator is located under the hood on the left side of the machine. Open the hood. Refer to the Operation and Maintenance Manual, "Access Doors and Covers" for the location of the hood.

Start the engine.

Run the engine at high idle.

Show/hide table




Illustration 1	g01674855

If the yellow piston in the engine air filter service indicator enters the red zone, service the air cleaner.

Stop the engine.

Note: See the Operation and Maintenance Manual, "Engine Air Filter Primary Element - Clean/Replace". See the Operation and Maintenance Manual, "Engine Air Filter Secondary Element - Replace".

In order to reset the air filter element indicator, push down on the button on top of the indicator.

Close the hood.

Caterpillar Information System:

CB54 and CB64 Vibratory Asphalt Compactors Drum Scrapers - Inspect/Adjust/Replace

CB54 and CB64 Vibratory Asphalt Compactors Drum Drive Planetary Oil - Change

CB54 and CB64 Vibratory Asphalt Compactors Cooling System Pressure Cap - Clean/Replace

CB54 and CB64 Vibratory Asphalt Compactors Cooling System Coolant Sample - Obtain

CB54 and CB64 Vibratory Asphalt Compactors Cooling System Coolant Sample (Level 2) - Obtain

CB54 and CB64 Vibratory Asphalt Compactors Cooling System Coolant Sample (Level 1) - Obtain

CB54 and CB64 Vibratory Asphalt Compactors Cooling System Coolant Level - Check

795F AC and 795F AC XQ Off-Highway Truck Power Train Electronic Control System Electrical Shutdown and Voltage Discharge

CB54 and CB64 Vibratory Asphalt Compactors Cooling System Coolant Extender (ELC) - Add

795F AC and 795F AC XQ Off-Highway Trucks Radiator Core and Aftercooler - Clean

2009/07/20 An Improved Planetary Carrier Is Now Used on Certain Off-Highway Trucks {3160}

793F WTR OEM Off-Highway Truck Hydraulic Fan and Steering System Solenoid Valve and Manifold (Rear Axle Fan, Lubrication, Steering) - Adjust

CB54 and CB64 Vibratory Asphalt Compactors Engine Oil Level - Check

422E, 428E, 432E, 434E, 442E and 444E Backhoe Loaders Machine Systems Quick Coupler - Remove and Install

2008/10/06 An Improved Bevel Gear Set is Now Used {3256}

2009/08/31 The Position Switch for the Truck Body has been Replaced {1408, 1435, 7258}

2008/10/13 A New Seal Kit is Available for Backhoe Loaders {4303}

422E, 428E, 432E, 434E, 442E and 444E Backhoe Loaders Machine Systems Bucket - Remove and Install - Multipurpose

422E, 428E, 432E, 434E, 442E and 444E Backhoe Loaders Machine Systems Backhoe Bucket Cylinder - Remove and Install

3408E and 3412E Engines for Caterpillar Built Machines Engine Oil Filter Bypass Valve

2009/03/23 Improved Valve Bridges {1102, 1121, 1123}

2008/11/17 Improved Electronic Unit Injectors for C6.6 and C4.4 Engines {1251, 1290}

793F and 793F XQ Off-Highway Truck Hydraulic Fan and Steering System Oil Filter (Case Drain)

2008/11/24 An Improved Connector is Available for Certain Motor Graders {1361, 1380}