Wiring Harness (Open Circuit) - Test
断路是指使电流不流动的电路故障。 断路通常是由电气导线故障或电气接头连接不良引起的。 电气导线或连接断开时,电路中的电流就会中断流动。 常闭电路的电阻值应小于 5 欧姆。 下述步骤将说明断路测试:
参考有关完整的电气示意图,参考正在维修的机器的电气系统示意图。
测试有无断路。
- 确定可疑电路中的接头和导线编号。 使用机器的电气系统示意图检查电路。
- 将钥匙起动开关和断路开关转到断开位置。
- 从配线线束上断开部件和 ECM。
- 在一个断开的线束连接上,将一根跨接导线连在可疑导线的触点与机架接地之间。
- 在其他机器线束接头上,使用万用表表笔测量可疑导线的触点与机架接地之间的电阻。
预期结果:电阻小于 5 欧姆。
确定 - 电阻小于 5 欧姆。 线束电路正常。
停止。
异常 - 电阻大于 5000 欧姆。 机器线束中存在断路。
修理:修理或更换机器线束。
停止。
Caterpillar Information System:
120K, 120K Series 2, 12K, 140K, 140K Series 2 and 160K Motor Graders Power Train Electronic Control System Electrical Output Components
120K, 120K Series 2, 12K, 140K, 140K Series 2 and 160K Motor Graders Power Train Electronic Control System Electronic Control Module (ECM)
PL61 Pipelayer Machine Systems Winch Frame - Remove
120K, 120K Series 2, 12K, 140K, 140K Series 2 and 160K Motor Graders Power Train Electronic Control System Electrical Input Components
120K, 120K Series 2, 12K, 140K, 140K Series 2 and 160K Motor Graders Power Train Electronic Control System Location of Electrical Components
120K, 120K Series 2, 12K, 140K, 140K Series 2 and 160K Motor Graders Power Train Electronic Control System Features
785D OEM Off-Highway Truck Machine Systems Steering Link - Remove and Install
Filtration Procedure for Wheel Loader, Wheel Dozer, Soil Compactor, Landfill Compactor Hydraulic Oil {0680, 0768, 5056, 5068} Filtration Procedure for Wheel Loader, Wheel Dozer, Soil Compactor, Landfill Compactor Hydraulic Oil {0680, 0768, 5056, 5068}
1390 Track Feller Buncher Swing System
1390 Track Feller Buncher Control Valve (Intermittent Saw) - If Equipped
PL61 Pipelayer Front Idler Position - Check/Adjust
Steering Clutch and Brake Discs and Plates for Scrapers, Pipelayers, Track-Type Tractors, and Loaders {4100, 4255} Steering Clutch and Brake Discs and Plates for Scrapers, Pipelayers, Track-Type Tractors, and Loaders {4100, 4255}
120K, 120K Series 2, 12K, 140K, 140K Series 2 and 160K Motor Graders Power Train Electronic Control System Wiring Harness (Short Circuit) - Test
120K, 120K Series 2, 12K, 140K, 140K Series 2 and 160K Motor Graders Power Train Electronic Control System Transmission Control (Shift Lever) - Test
120K, 120K Series 2, 12K, 140K, 140K Series 2 and 160K Motor Graders Power Train Electronic Control System Speed Sensor - Adjust
120K, 120K Series 2, 12K, 140K, 140K Series 2 and 160K Motor Graders Power Train Electronic Control System Electronic Control Module (ECM) - Flash Program
120K, 120K Series 2, 12K, 140K, 140K Series 2 and 160K Motor Graders Power Train Electronic Control System Electronic Control Module (ECM) - Configure
120K, 120K Series 2, 12K, 140K, 140K Series 2 and 160K Motor Graders Power Train Electronic Control System Electronic Control Module (ECM) - Replace
120K, 120K Series 2, 12K, 140K, 140K Series 2 and 160K Motor Graders Power Train Electronic Control System System Schematic
120K, 120K Series 2, 12K, 140K, 140K Series 2 and 160K Motor Graders Power Train Electronic Control System General Information
120K, 120K Series 2, 12K, 140K, 140K Series 2 and 160K Motor Graders Power Train Electronic Control System Service Tools
120K, 120K Series 2, 12K, 140K, 140K Series 2 and 160K Motor Graders Power Train Electronic Control System Connector Locations
120K, 120K Series 2, 12K, 140K, 140K Series 2 and 160K Motor Graders Power Train Electronic Control System Diagnostic Capabilities
785D OEM Off-Highway Truck Machine Systems Air Tank (Primary) - Remove and Install