Transmission Planetary and Transfer Gears - Install
安装步骤
Show/hide table
所需工具     | |||
工具     | 零件号     | 零件说明     | 数量     |
A     | 1U-9200     | 操纵杆滚轮起重机     | 1     |
B     | 138-7575     | 连杆支架     | 2     |
- 将工具 (A) 、工具 (B) 和适当的起吊设备固定到变速箱行星齿轮和分动器 (17) 上。 变速箱行星齿轮和分动器 (17) 的重量约为 1134 kg (2500 lb)。
Show/hide table
图 1 | g01408552 |
- 利用工具 (A) 和 (B) 定位变速箱行星齿轮和分动器 (17) 。 降下变速箱行星齿轮和分动器 (17) ,以便于安装。
- 安置支架组件 (25) 并安装螺栓 (23) 。 安装销 (24) 后安装螺栓 (22) 。
Show/hide table
图 2 | g01408550 |
- 安装支架组件 (20) ,然后安装螺栓 (21) 。 连接软管组件 (19) 。
Show/hide table
图 3 | g01408549 |
- 安装螺栓 (18) 。
Show/hide table
图 4 | g01408548 |
- 将工具 (A) 、工具 (B) 和全部适当的起吊设备从变速箱行星齿轮和分动器 (17) 上拆下。
Show/hide table
图 5 | g01408546 |
- 连接软管组件 (16) 。
Show/hide table
图 6 | g01408545 |
- 连接夹子 (15) 。
Show/hide table
图 7 | g01408544 |
- 连接线束组件 (14) ,然后安装螺栓 (13) 。 拧紧螺栓 (13) 至扭矩为 2.25 ± 0.25 N·m (20.0 ± 2.2 lb in)。 连接夹子 (12) 。
Show/hide table
图 8 | g01408543 |
- 安装防护罩组件 (11) 。 连接软管组件 (10) 。 安装软管组件 (9) 。 连接夹子 (7) 和 (8) 。
Show/hide table
图 9 | g01408541 |
- 连接软管组件 (6) 。
Show/hide table
图 10 | g01408539 |
- 连接管组件 (5) 。 连接线束组件 (4) 。
Show/hide table
图 11 | g01408537 |
- 安置护罩 (2) 并安装螺栓 (3) 。 连接夹子 (1) 。
Show/hide table
图 12 | g01408520 |
- 给变速箱行星齿轮和分动器加油。 请参阅操作和保养手册, "变速箱行星齿轮和分动器 - 更换"。
End By:
- 安装后驱动轴 。 请参阅 拆解和组装, "驱动轴(后)- 拆卸和安装"。
- 安装前驱动轴。 请参阅 拆解和组装, "驱动轴(前)- 拆卸和安装"。
- 拆下销后降下车斗。 请参阅 拆解和组装, "销(车斗固定)- 拆卸和安装"。
Caterpillar Information System:
140M Motor Grader Engine Supplement Radiator - Install
770 and 772 Off-Highway Trucks Power Train Transmission Planetary and Transfer Gears - Remove
CP54 and CS54 Vibratory Soil Compactors Machine Systems Hydraulic Cylinder (Cab Tilt)
CP54 and CS54 Vibratory Soil Compactors Machine Systems Muffler
2007/08/27 A New Chassis Harness is Now Available Without a Diode Which Will Prevent Engine Overheating on Asphalt Pavers {1408}
14L Motor Grader Machine Systems Tie Rod (Steering) - Remove and Install
904B, 906 and 908 Compact Wheel Loaders, IT14G and IT28G Integrated Toolcarriers and 914G, 924G, 924GZ, 928G and 930G Wheel Loaders Steering Column Play - Check
770 and 772 Off-Highway Trucks Power Train Transmission Planetary and Transfer Gears - Connect
770 and 772 Off-Highway Trucks Power Train Transmission Planetary and Transfer Gears - Separate
2007/08/27 Changes to Testing and Adjusting, RENR4897, "216B, 226B, 232B, and 242B Skid Steer Loaders Machine Systems" , "Hydrostatic System - Test and Adjust" {4350, 4350}
CP56, CS56, CP64, CS64, CP74 and CS74 Vibratory Soil Compactors Machine Systems Suction Fan
CP56, CS56, CP64, CS64, CP74 and CS74 Vibratory Soil Compactors Machine Systems Gear Motor (Fan Drive)
TH580B Telehandler Fuel System Primary Filter (Water Separator) Element - Replace
14M and 16M Motor Graders Machine Systems Lubrication System - If Equipped
2007/08/27 Changes to Testing and Adjusting, RENR4897, "216B, 226B, 232B, and 242B Skid Steer Loaders Machine Systems" , "Main Relief Valve - Test and Adjust" {5069, 5069}
2007/08/27 Changes to Testing and Adjusting, RENR4897, "216B, 226B, 232B, and 242B Skid Steer Loaders Machine Systems" , "Line Relief Valve - Test and Adjust" {5117, 5117}
CP76 and CS76 Vibratory Compactors Machine Systems Case Drain Flow for Piston Motor (Vibratory) - Test
2007/08/27 Changes to Testing and Adjusting, RENR4897, "216B, 226B, 232B, and 242B Skid Steer Loaders Machine Systems" , "Worksheets - Troubleshoot" {4350, 5050}
CP76 and CS76 Vibratory Compactors Machine Systems Gear Pump Flow (Cooling Fan) - Test
CS54 and CP54 Vibratory Soil Compactors Engine and Machine Warm-Up
CP54 and CS54 Vibratory Soil Compactors Machine Systems Engine Service Group
3176C Engine for the R1600G and the R1700G Load Haul Dumps Speed/Timing - Test
14M and 16M Motor Graders Machine Systems Lubrication System
140M Motor Grader Engine Supplement Refrigerant Condenser - Remove and Install