Troubleshooting
Show/hide table
图 1 | g01289644 |
在分析仪存在故障指示时的情况下进行操作时,对 6V-2150 起动/充电分析仪 进行故障诊断和排除
分析仪中存在故障指示。 该步骤将有助于查找故障。
- 拆下发动机或更换配线线束等在机器上进行的修理工作可能导致该故障。 可能的故障列表如下:
- 机器配线线束的连接错误
- 诊断接头的配线错误
注: 当故障为配线错误时,使用数字万用表在正确的配线线束上进行测试。 有关更多信息,请参阅系统操作, "测试考虑因素"部分中分析仪测试的解释。
- 机器配线正确且分析仪不显示预期结果。 使用状态良好的分析器,然后重复本测试。
如果分析仪故障,请参阅系统操作, "参考信息"。
Caterpillar Information System:
R1700G Load Haul Dump Steering System Diverter Valve (Steering Release)
R1600G Load Haul Dump Steering System Diverter Valve (Steering Release)
R1700G Load Haul Dump Brake Release - If Equipped
Starting and Charging Systems Test Step D, High Idle
Starting and Charging Systems Test Step C, Start Aid
2007/04/30 A New Valve Improves the Service Life of the Circle Drive Motors {5057, 5082, 5207}
Machine Start Switch Key May Not Fit Properly{1416} Machine Start Switch Key May Not Fit Properly{1416}
Starting and Charging Systems Test Step B, Crank
854K Wheel Dozer Hydraulic System Pressure Switch (Oil Filter Bypass)
Starting and Charging Systems Test Setup A, Hookup
CB-534D and CB-564D Asphalt Compactors Sound Information and Vibration Information
Starting and Charging Systems Basic Operation
Installing a Ride Control Kit{1408, 5004, 5057, 5077} Installing a Ride Control Kit{1408, 5004, 5057, 5077}
Starting and Charging Systems Test Considerations
793D Off-Highway Truck Power Train Tire and Rim (Rear) - Remove
793D Off-Highway Truck Power Train Tire and Rim (Rear) - Install
RM-500 Road Reclaimer/Soil Stabilizer Machine Systems Control Valve (Hood Tilt, Manual Brake Release)
RM-500 Road Reclaimer/Soil Stabilizer Machine Systems Control Valve (Parking and Rotor Brake Release)
C27 and C32 Engines for Caterpillar Built Machines Mass Air Flow Sensor
773E, 773F, 775F, 777E, and 777F Off-Highway Truck Brake Electronic Control System MID 116 - CID 0713 - FMI 03
2006/06/05 New Exhaust Temperature Sensors Are Now Used {1919}
990K Wheel Loader Electronic Unit Injector - Inspect/Adjust
2006/10/23 An Improved Torque Converter Turbine is Now Used In the Torque Converter Group {3101}
Starting and Charging Systems Starter Ground Circuit Test Description