E197 High Engine Oil Temperature
产生此代码的情况:
电子控制模块（ECM）可检测以下状况：
E197-1 警告
- 发动机至少已运转三秒钟。
- ECM 检测到发动机机油温度过高持续十秒钟。
- 发动机机油温度超过停机激发点。
E197-3 停机
- 发动机至少已运转三秒钟。
- ECM 检测到发动机机油温度过高持续十秒钟。
- 发动机机油温度超过停机激发点。
系统响应:
E197-1
ECM 将触发一个快照。 记录事件代码。
E197-3
ECM 将触发一个快照。 记录事件代码。 发动机将停机。
E197-1
不会立即影响发动机的运转。 但是，如果发动机机油温度继续升高，发动机可能停机。
E197-3
发动机将停机。
测试步骤 1.
请参阅故障诊断与排除, "发动机机油温度过高"。
结果:
- 正常 - 停止
Caterpillar Information System:
446D Backhoe Loader Engine Oil and Filter - Change
CB-214E, CB-224E and CB-225E Paving Compactors Tire Shipping Pressure
446D Backhoe Loader Engine Oil Sample - Obtain
C15 and C18 Generator Set Engines Inlet and Exhaust Valves - Remove and Install
446D Backhoe Loader Axle Oscillation Bearings - Lubricate
CB-214D, CB-224D and CB-225D Vibratory Compactors Machine Systems Metering Pump (Steering) - Remove and Install
CB-214E, CB-224E and CB-225E Paving Compactors Isolation Mounts - Inspect
Conversion of High Flow Work Tools For Operation on High Flow Skid Steer Loaders and Multi Terrain Loaders{1408, 5057, 7553} Conversion of High Flow Work Tools For Operation on High Flow Skid Steer Loaders and Multi Terrain Loaders{1408, 5057, 7553}
446D Backhoe Loader Engine Oil Level - Check
446D Backhoe Loader Engine Air Precleaner - Clean
2004/02/16 Correction to Testing and Adjusting , "Piston Pump Neutral - Test and Adjust" {5070}
446D Backhoe Loader Engine Crankcase Breather - Clean
CB-214D, CB-224D and CB-225D Vibratory Compactors Machine Systems Hydraulic Cylinder (Steering) - Remove and Install
R2900G Load Haul Dump Power Train Electronic Control System Connector Locations
R2900G Load Haul Dump Power Train Electronic Control System Electronic Control Module (Power Train) - Replace
R1300G Load Haul Dump Power Train Trunnion Support (Oscillating Axle, Rear) - Remove
2003/12/29 New Retaining Ring in Gear Clutch Is Now Used. {3155}
2003/12/29 A New Retaining Ring Is Now Used in the Forward Low and Reverse Clutches {3155}
2004/03/15 Changes to the Steering System {4300}
2004/03/15 A Seal Kit for the Retract Section of the Hydraulic Pump Is Now Available {5055, 5070}
CB-214E, CB-224E and CB-225E Paving Compactors Seat
247B, 257B, 267B, 277B and 287B Multi Terrain Loaders and 216B, 226B, 232B, 236B, 242B, 246B, 248B, 252B, 262B and 268B Skid Steer Loaders Auxiliary Hydraulic Electronic Control System MID 106 - CID 1935 - FMI 04
735 Articulated Truck Suspension System - Check
CP-323C and CS-323C Paving Compactors Cooling System Coolant Extender (ELC) - Add