CID 0581 FMI 05 Power Shift Solenoid open circuit
Conditions Which Generate This Code:
The Electronic Control Module (ECM) detects all of the following conditions:
- An open circuit condition has existed for at least 0.15 seconds.
- Desired current is greater than 0.55 Amp.
- Battery voltage is greater than 9 VDC for the last two seconds.
- The ECM has been powered for at least three seconds.
System Response:
The ECM will log the diagnostic code. The diagnostic code may be viewed on a display module or on the Caterpillar Electronic Technician (Cat ET). The "Underspeed" feature is disabled.
- None
Test Step 1. Perform the following test: Power Shift Solenoid Circuit - Test
Results:
- OK - Stop.
Caterpillar Information System:
797 Off-Highway Truck Power Train Transmission Hydraulic Control - Disassemble
D350E Series II, D400E Series II and D400E Series II Ejector Articulated Trucks Braking System Pressure and Flow Compensator Valve (Brake) - Test and Adjust
D250E Series II and D300E Series II Articulated Trucks Operator's Compartment
D350E Series II, D400E Series II and D400E Series II Ejector Articulated Trucks Braking System Service Brake Air - Purge
Alternator - Delco 21SI Component Description
CB-535B Vibratory Compactor Steering System Wheel Tilt Hydraulic System
CB-535B Vibratory Compactor Steering System Gear Pump (Charge, Steering, Offset and Wheel Tilt)
784C, 785B, 785C, 785D, 789B, 789C, 789D, 793B, 793C, 793D, 797, and 797B Off-Highway Trucks Vital Information Management System (VIMS) General Information
3408E and 3412E Engines for Caterpillar Built Machines CID 0275 FMI 04 Right Turbo Inlet Pressure short to ground
3456 Engine, 836G Landfill Compactor, 834G Wheel Dozer and 988G Wheel Loader CID 0274 FMI 04 Atmospheric Pressure short to ground
3412E Engine for Caterpillar Built Machines CID 0580 FMI 04 Power Shift Pres Sensor short to ground
CB-535B Vibratory Compactor Steering System Metering Pump (Steering)
3412E Engine for Caterpillar Built Machines CID 0581 FMI 06 Power Shift Solenoid short to ground
2000/02/14 Improved Transmission Direction Rocker Switch is Now Available {1611}
CS-431C, CP-433C and CS-433C Vibratory Compactors Vibratory System Support and Vibratory Drive
CP-433C, CS-431C and CS-433C Paving Compactors Engine Water Pump - Inspect
3500 Engines with EUI Option Cat Data Link
3500B and 3500B High Displacement Generator Set Engines Fuel Rate Scaling (Fuel Correction Factor) - Diesel Fuel
CB-535B Vibratory Compactor Ring Bearings - Lubricate
3500B Engines Fuel Injector Mechanism
CS-431C, CP-433C and CS-433C Vibratory Compactors Vibratory System Vibratory Support
CB-535B Vibratory Compactor Windows - Clean
3516B Generator Set Engines with Dynamic Gas Blending Aftercooler - Jacket Water Aftercooler
CB-535B Vibratory Compactor Window Wiper and Washer Control