Differential and Bevel Gear
注: 有关差速器和锥齿轮的正确调整步骤,请参考测试和调整, "差速器和锥齿轮 - 调整"。
Show/hide table
图 1 | g00903473 |
Show/hide table
图 2 | g00903449 |
B-B 视图 |
Show/hide table
图 3 | g00903481 |
C-C 视图 |
(1) 安装前,将 155-0695 螺纹锁固胶 涂在螺栓的螺纹上。
(2) 四只螺栓的扭矩 ... 1600 ± 150 牛米 (1180 ± 110 磅英尺)
Show/hide table
图 4 | g00903291 |
剖面图 A-A |
(3) 26 只螺母的扭矩 ... 430 ± 60 牛米 (317 ± 44 磅英尺)
(4) 24 只螺母的扭矩 ... 440 ± 40 牛米 (325 ± 30 磅英尺)
(5) 将两个销钉安装在孔上。 ... 8.0 ± 1.0 毫米 (0.32 ± 0.04 英寸)
(6) 使用少量润滑剂来润滑要密封的孔。
(7) 9M-5874 垫片组
- 数量 ... 根据需要
- 垫片组的厚度 ... 0.130 毫米 (0.005 英寸)
(8) 24 只螺母的扭矩 ... 430 ± 60 牛米 (317 ± 44 磅英尺)
(9) 24 只双头螺栓的扭矩 ... 170 ± 30 牛米 (125 ± 22 磅英尺)
(10) 以 50 ± 5 牛米 (37 ± 4 磅英尺)的扭矩拧紧 18 只螺栓。 然后,将 18 只螺栓再拧 60 ± 5 度。
(11) 使用少量润滑剂来润滑要密封的密封唇口。
(12) 垫片
-
132-6757 垫片
- 数量 ... 根据需要
- 厚度 ... 0.12 ± 0.015 毫米 (0.005 ± 0.0006 英寸)
-
132-6758 垫片
- 数量 ... 根据需要
- 厚度 ... 0.18 ± 0.015 毫米 (0.007 ± 0.0006 英寸)
注: 请参考测试和调整, "差速器和锥齿轮 - 调整"。
(A) 外罩和锥齿轮的间隙 ... 1.0 + 2.0/−0.5 毫米 (0.039 +0.079/−0.0197 英寸)
Caterpillar Information System:
AP-1050B and BG-245C Asphalt Pavers Engine Starting with Air Inlet Heater
AP500F Asphalt Paver Starting Motor - Inspect
AP-1050B and BG-245C Asphalt Pavers Stopping the Machine
AP-1050B and BG-245C Asphalt Pavers Stopping the Engine
8-16B, 10-20B and 10-20WB Extend-A-Mat<COMP-BREAK TAGNAME=cp850>©<COMP-RESUME> Screed Setting the Paver Speed
784C, 785C and 785C HAA Off-Highway Truck/Tractors Power Train Bypass Switch (Transmission Lubrication Filter)
950G Wheel Loader, 962G Wheel Loader and IT62G Integrated Toolcarrier Steering System Secondary Steering System - Conventional Steering
Caterpillar<COMP-BREAK TAGNAME=cp850>©<COMP-RESUME> AP-650B and Barber-Greene<COMP-BREAK TAGNAME=cp850>©<COMP-RESUME> BG-225C Asphalt Pavers Shipping the Machine
Caterpillar<COMP-BREAK TAGNAME=cp850>©<COMP-RESUME> AP-650B and Barber-Greene<COMP-BREAK TAGNAME=cp850>©<COMP-RESUME> BG-225C Asphalt Pavers Tow Point Cylinders
AP500F Asphalt Paver Towing the Machine
Caterpillar<COMP-BREAK TAGNAME=cp850>©<COMP-RESUME> AP-650B and Barber-Greene<COMP-BREAK TAGNAME=cp850>©<COMP-RESUME> BG-225C Asphalt Pavers Track Tension - Check
950G Wheel Loader, 962G Wheel Loader and IT62G Integrated Toolcarrier Power Train Transmission Hydraulic System
784C, 785C and 785C HAA Off-Highway Truck/Tractors Power Train Flow Control and Relief Valve (Rear Axle Oil)
950G Wheel Loader, 962G Wheel Loader and IT62G Integrated Toolcarrier Hydraulic System Relief Valve (Line)
Caterpillar<COMP-BREAK TAGNAME=cp850>©<COMP-RESUME> AP-650B and Barber-Greene<COMP-BREAK TAGNAME=cp850>©<COMP-RESUME> BG-225C Asphalt Pavers Stopping the Engine if an Electrical Malfunction Occurs
793B Off-Highway Truck Engine Valve Lash and Bridge - Adjust
Caterpillar<COMP-BREAK TAGNAME=cp850>©<COMP-RESUME> AP-650B and Barber-Greene<COMP-BREAK TAGNAME=cp850>©<COMP-RESUME> BG-225C Asphalt Pavers Ventilation Blower Wheel - Inspect/Clean
3054 Engine General Information
793B Off-Highway Truck Air System and Brakes Screen (Torque Converter and Front Brake Cooling)
583R Pipelayer Differential and Final Drive Oil Sample - Obtain
789C Off-Highway Truck/Tractor Rear Axle Housing
Caterpillar<COMP-BREAK TAGNAME=cp850>©<COMP-RESUME> AP-650B and Barber-Greene<COMP-BREAK TAGNAME=cp850>©<COMP-RESUME> BG-225C Asphalt Pavers Conveyor Electronic Control Module
3500B Engines for Caterpillar Built Power Modules Fuel Pressure Sensor
572R Pipelayer Battery, Battery Cable or Battery Disconnect Switch - Replace