A New Antenna Assembly is Now Used on Certain Off-Highway Trucks {733B}
- OEM
- CAT WDS (S/N: M6J1-125)
- Off-Highway Truck/Tractor
- 770G (S/N: RMA1-101; TWA1-152; KDH1-372; ECM1-337,340-340; ECX1-114)
- 772G (S/N: LTS1-1,254-400,402-404; KEX1-1,103-272; LTX1-210)
- 777G (S/N: GT71-170; T5A1-123; TNM1-884,1000-1018; RDR1-385,500-505; T4Y1-210,500-500)
- 772G (S/N: LTS1-1,254-400,402-404; KEX1-1,103-272; LTX1-210)
- Quarry Truck
- 773G (S/N: MWH1-422; JWS1-387; T5S1-126; T5T1-106)
- 775G (S/N: T5F1-103; RFM1-921; MJS1-575; T5W1-112)
Reference: Refer to Special Instruction, M0080381, "Procedure to Install an Improved Antenna Assembly on Certain Off-Highway Trucks".
Description Of Change: The new cable assembly and antenna assembly on the cab has been improved on certain 770G - 777G Off-Highway Trucks. The new antenna assembly improved fatigue life at the base pivot joint of antenna assembly.
Adaptable To: The following parts are adaptable to the machines within the listed serial numbers, and are effective with all machines after the listed serial numbers.
Show/hide table
| Required Parts | ||||
|---|---|---|---|---|
| Item | Qty | New Part Number | Description | Former Part Number |
| 1 | 1 | Antenna As | ||
| 2 | 1 | Cable As | ||
| 3 | 38 | Cable Strap | ||
Show/hide table
| |
| Illustration 1 | g06174337 |
|
View of Antenna Assembly and Cable Assembly 770G and 772G (1) (2) (3) | |
Show/hide table
| |
| Illustration 2 | g06177372 |
|
View of Antenna Assembly and Cable Assembly 773G, 775G, 777G (1) (2) (3) | |
The Special Instruction is available through the normal literature distribution system. The publication can also be found on the Caterpillar Service Information System (SIS).
Caterpillar Information System:
C8.7 and C12.9 Marine Engines Injector Solenoid - Test
SR500 Generators Generator Load - Check
C8.7 and C12.9 Marine Engines Air Inlet Heater Circuit - Test
SR500 Generators Single Unit Operation
C9.3B Engine Injector Code - Calibrate
C12.9 Marine Propulsion Engine Engine Valve Lash - Inspect/Adjust
3512B Generator Set Engines with Dynamic Gas Blending Engine Top Speed Is Not Obtained
C13, C15, and C18 Generator Set Engines CID 1901 FMI 05 Intake Valve Actuator #1 Current Below Normal
C13, C15, and C18 Generator Set Engines CID 0544 FMI 08 Engine Cooling Fan Speed signal abnormal
C13, C15, and C18 Generator Set Engines CID 0544 FMI 02 Engine Cooling Fan Speed Sensor loss of signal
C13, C15, and C18 Generator Set Engines CID 0269 FMI 04 Sensor Supply too low
C13, C15, and C18 Generator Set Engines CID 0269 FMI 03 Sensor Supply too high
Procedure to Install an Improved Antenna Assembly on Certain Off-Highway Trucks {733B} Procedure to Install an Improved Antenna Assembly on Certain Off-Highway Trucks {733B}
C7.1 Marine Propulsion Engine Fuel Tank Water and Sediment - Drain
Primary Engine Speed Sensor Malfunctioning, Shorted, Open Circuit {1907, 1912} Primary Engine Speed Sensor Malfunctioning, Shorted, Open Circuit {1907, 1912}
C7.1 Marine Propulsion Engine Hoses and Clamps - Inspect/Replace
C9.3B Engines for Caterpillar Built Machines Inlet Manifold - Remove and Install
C7.1 Marine Propulsion Engine Overhaul (Top End)
C175 Tier 4 Final Engines for Off-Highway Trucks Cat ET Service Features
C7.1 Marine Propulsion Engine Sea Water Strainer - Clean/Inspect
C7.1 Marine Propulsion Engine Engine Rating Definitions
New Injector Wiring Harness Group for C7 Engines {1403} New Injector Wiring Harness Group for C7 Engines {1403}
New Software is Used For Some C9.3 Through C18 Tier 4 Engines {1920} New Software is Used For Some C9.3 Through C18 Tier 4 Engines {1920}
Selective Catalytic Reduction Retrofit Aftertreatment - Airless Dosing Diesel Exhaust Fluid Quality - Test